Abstract:In actual combustion facilities, coal chars are often generated using a variety of pyrolysis processes, such as secondary pyrolysis, which is characterized by a long residence time in high temperature zone. The effects of such processes on the conversion of char N to NO during combustion have seldom been explored. In this study, the releases of NO during the combustion of coal chars obtained from different pyrolysis processes in a drop tube and in a fixed bed reactor were investigated. In addition, the extent of char N/NO conversion was studied in relation to the char reactivity, pore surface structure and carbon conversion in a horizontal tube furnace. The results show that, compared with chars generated by a single pyrolysis, chars treated by a subsequent secondary pyrolysis process exhibit larger pore surface areas but less reactivity because of the thermal annealing resulting from a longer thermal history. Chars with higher intrinsic reactivity were also found to release a lower amount of NO. However, a weak correlation was identified between the apparent reactivity and char N/NO conversion, indicating that intrinsic reactivity is more important and directly determines the NO reduction process under combustion conditions. Moreover, char N/NO conversion was significantly affected by the coal rank, and a greater extent of conversion of char N to NO was observed in the case of high-rank coal chars. At a high combustion temperature (1373 K), variations in the bulk O-2 concentration had little effect on the char N/NO conversion, and an apparent correlation was found between the extents of char N/NO conversion and the accessible pore surface area. These results indicate that at high temperatures, the char N/NO conversion is directly determined by the accessible pore surface area due to transportation limitations. The NO/(CO + CO2) ratio increased with increasing burn-off in the latter stages of char conversion, which can be attributed to decreases in both the BET surface area and accessible pore surface area available for NO reduction during combustion.

Effect of high-temperature and microwave expanding modification on reactivity of coal char for char-NO interaction

Effect of microwave modification on pulverized coal combustion properties

Effect of Microwave Treatment on the Reactivity of Synthetic Coal Char for No Reduction

Experimental research on combustion of modification Yangquan coal

EFFECT OF MICROWAVE IRRADIATION ON GRAPHITIZATION OF CARBON MATRIX IN PULVERIZED COAL

Experimental study on the co-firing and NOx emission characteristics of bituminous coal and its medium temperature pyrolysis char

Experiment Research on Combustion of Microwave Modified Pc

Kinetics of Microwave Radiation Pulverized Coal Combustion Based on Non-Isothermal Thermogravimetric Analysis

Experimental and DFT Research on the Effects of O2/CO2 and O2/H2O Pretreatments on the Combustion Characteristics of Char

Experimental and modeling investigation on char combustion and char-nitrogen evolution characteristics under different conditions

Effect of Volatile-Char Interaction on the No Emission from Coal Combustion

Non-pyrolysis microwave heating as coal pretreatment for in-situ combustion: reactivity and microstructure

Experimental Study on No Heterogeneous Reduction by Char

NO Reduction and Emission Characteristics of Coal/Char Mixtures in a Microfluidized Bed Reaction Analyzer

Effect of Volatile-Char Interaction on Nitrogen Oxide Emission During Combustion of Blended Coal

Nitrogen/NO Conversion Characteristics of Coal Chars Prepared Using Different Pyrolysis Procedures under Combustion Conditions

Effects of Reaction Condition on NO Emission Characteristic, Surface Behavior and Microstructure of Demineralized Char During O2/H2O Combustion Process

Modeling NO−Char Reaction at High Temperature

Evolution of Char Structure During Non-Isothermal Low Temperature Pyrolysis of ZhunDong Coal by Microwave Heating: A Comparative Study with Conventional Heating

Effect of Nitriding Treatment on Char Reducing Nitric Oxide at High Temperature

Investigation on the interaction of NH3&CH4 co-activated char under reburning conditions