Abstract:In this study, three different approaches, i.e. the sol-gel method, precipitation method and hard-template method, were applied to synthesize MgF2 catalysts with improved stability towards the dehydrofluorination of hydrofluorocarbons (HFCs); the in situ XRD technique was employed to investigate the relationship between the calcination temperature and the crystallite size of precursors to determine optimal calcination temperature for the preparation of the MgF2 catalysts. Moreover, the physicochemical properties of MgF2 catalysts were examined via BET, XRD, EDS and TPD of NH3 and compared. Undoubtedly, the application of different methods had a significant influence on the surface properties and catalytic performances of MgF2 catalysts. The surface areas of the catalysts prepared by the precipitation method, sol-gel method and template method were 120, 215 and 304 m2 g-1, respectively, upon calcination at 200 °C. However, the surface area of the MgF2 catalysts decreased significantly when the calcination temperatures of 300 and 350 °C were applied. The catalytic performance of these catalysts was evaluated via the dehydrofluorination of 1,1-difluoroethane (HFC-152a). The MgF2 catalyst prepared by the precipitation method showed the lowest catalytic activity among all the MgF2 catalysts. When the calcination temperature was above 300 °C, the MgF2 catalysts prepared via the template method demonstrated the highest catalytic conversion rate with catalytic activity following the order: MgF2-T (template method) > MgF2-S (sol-gel method) > MgF2-P (precipitation method). The conversion rate generally agreed with the total amount of acid on the surface of the catalysts, which was measured by the NH3-TPD technique. The MgF2-T catalysts were further examined for the dehydrofluorination of HFC-152a for 600 hours, and a conversion rate greater than 45% was maintained, demonstrating superior long-term stability of these catalysts.

Synthesis of titanium oxyfluoride with oxygen vacancy as novel catalysts for pyrolysis of fluorinated greenhouse gasses to hydrofluoroolefins

A Mechanistic Study of the Hydrolysis of Tetrafluoromethane on Γ-Alumina

Direct Production of Hydrocarbons by Fischer-Tropsch Synthesis Using Newly Designed Catalysts

Selective Aerobic Oxidation of Aromatic Alcohols Catalyzed by Tio(2): an Insight on the Effect of Surface Fluorination

Evolution of Lewis acidity by mechanochemical and fluorination treatment of silicon carbide as novel catalyst for dehydrofluorination reactions

Synthesis of 2,3,3,3-tetrafluoropropene by catalytic dehydrofluorination of 1,1,1,3,3-pentafluoropropane over Ni-Cr 2 O 3 catalyst

Sulfate ion induced formation of unsaturated coordination of AlF 3 nanocluster catalyst confined in carbon framework for catalytic dehydrofluorination

Solution Combustion Synthesis of Cr₂O₃ Nanoparticles and the Catalytic Performance for Dehydrofluorination of 1,1,1,3,3-Pentafluoropropane to 1,3,3,3-Tetrafluoropropene

Preparation of 1,1,1, 2-tetrafluoroethane (HFC-13 4a) by vapor-phase catalytic fluorination

Enhanced surface Lewis acidity of ZrO2 by ‒HSO4 for efficient CF4 decomposition

Efficient Photocatalytic Oxidation of Gaseous Toluene over F-doped TiO2 in a Wet Scrubbing Process

Pyrolysis of a Perfluoro Copolymer and Its Contribution to Hydrogen Fluoride (HF)

Fluorinated TiO2 Coupling with Α-Mno2 Nanowires Supported on Different Substrates for Photocatalytic VOCs Abatement under Vacuum Ultraviolet Irradiation

Super-hydrophobic Fluorination Mesoporous MCF/TiO2 Composite As a High-Performance Photocatalyst

Stabilizing F-Al-O active center via confinement of Al 2 O 3 in SiC framework for conversion of 1,1-difluoroethane greenhouse gas

Hydrophobic modification for CO photo-hydrogenation to olefins with low CO2 selectivity

Confined aluminum fluoride layers derived from the in situ etching of Ti3AlC2 as the robust catalyst for dehydrofluorination reaction

Rational design of MgF2 catalysts with long-term stability for the dehydrofluorination of 1,1-difluoroethane (HFC-152a)

Amorphous titanium dioxide with abundant defects induced by incorporation of silicon dioxide: A potential non-radical activator of hydrogen peroxide

Hydrophobic Fe‐Based Catalyst Derived from Prussian Blue for Enhanced Photothermal Conversion of Syngas to Light Olefins

Fluorine-induced oxygen vacancies on TiO2 nanosheets for photocatalytic indoor VOCs degradation