Abstract:The distribution tendency of the alloying elements in the body-centered cubic (bcc) Fe/B2–NiAl interface is of fundamental importance for understanding the nucleation and morphology of NiAl precipitates during the aging process of the B2–NiAl precipitation strengthened maraging steels. In the present work, the first-principles density functional calculations have been used to perform an extensive investigation on the segregation tendency of the common alloying elements in the bcc-Fe/NiAl interface and the resulting effects on the interfacial energy and the nucleation parameters of NiAl nuclei in the dilute solid solution FenNiAl. It was found that the coherency strain energy for forming coherent bcc-Fe/NiAl interfaces accounts for approximately 11% of the total nucleation free energy of NiAl phase, and the interfacial energies of bcc-Fe/NiAl at 0 K are 33 mJ/m2, 53 mJ/m2 and 37 mJ/m2 for (100), (110) and (111) planes, respectively. Based on the investigations of the sublattice site preference of the solute atoms in NiAl bulk, the segregation energies of the alloying elements in the interface were calculated and the results indicate that Si, Ti, V, Mn, Nb, Y, La, Cr, Co, Cu and Mo energetically prefer to segregate to the interface, and the segregations result in the corresponding changes of interfacial energy. Among these segregation solutes, La, Cr and Mo decrease both critical nucleation radius and the nucleation barrier of NiAl nuclei in the dilute solid solution FenNiAl, and the other alloying elements exhibit the inverse effects.

Precipitate size dependence of Ni/Ni3Al interface energy

Site preference of S-doping and its influence on the properties of a Ni/Ni3Al interface

Determination of γ/γ' interface free energy for solid state precipitation in Ni-Al alloys from molecular dynamics simulation

A Molecular Dynamics Study on the Dislocation-Precipitate Interaction in a Nickel Based Superalloy During the Tensile Deformation

Size dependence of incipient dislocation plasticity in Ni3Al

Size effects of γ′ precipitate on the creep properties of directionally solidified nickel-base super-alloys at middle temperature

Segregation of alloying elements at the bcc-Fe/B2–NiAl interface and the corresponding effects on the interfacial energy

Atomic study on the interaction between superlattice screw dislocation and γ-Ni precipitate in γ′-Ni3Al intermetallics

Size effect on the plastic deformation of pre-void Ni/Ni3Al interface under uniaxial tension: A molecular dynamics simulation

Insight into γ-Ni/γ′-Ni3Al interfacial energy affected by alloying elements

Size Effects Of Gamma ' Precipitate On The Creep Properties Of Directionally Solidified Nickel-Base Super-Alloys At Middle Temperature

Influence of interfacial dislocation network on strain-rate sensitivity in Ni-based single crystal superalloys

Ni/Ni3Al interface-dominated nanoindentation deformation and pop-in events

Nanostructure, Plastic Deformation, and Influence of Strain Rate Concerning Ni/Al2O3 Interface System Using a Molecular Dynamic Study (LAMMPS)

Mechanical Response and Plastic Deformation in the B2-NiAl/Fe Interface: Molecular Dynamics Analysis

Misfit dislocation networks in the γ/γ' phase interface of a Ni-based single-crystal superalloy : Molecular dynamics simulations

PRECIPITATE SIZE AND MORPHOLOGY EFFECTS ON THE CREEP BEHAVIOR OF NICKEL-BASE SUPERALLOYS

Molecular Dynamics Simulation of Atomic Configurations at Γ/γ′ (001) Interface in Ni-based Single-Crystalline Superalloys

Tension-compression asymmetry in Ni/Ni 3 Al interfaces: An atomistic investigation

The effects of elastic interactions on precipitate microstructural evolution in elastically inhomogeneous nickel-base alloys

Influence of Re on the Propagation of A Ni/Ni-3 Al Interface Crack by Molecular Dynamics Simulation