Abstract:Magnesium salts are commonly employed as ammonium-free leaching agents in the extraction of weathered crust elution-deposited rare earth ores (WCE-REO). Nonetheless, these salts frequently face technical challenges, including relatively low leaching rates and inadequate permeability in the in-situ leaching process. In this study, cetyltrimethylammonium chloride (CTAC) was used as a novel leaching aid agent to improve the rare earth leaching process. The effects of CTAC and pH on the rare earth leaching behavior and permeability was investigated. The leaching kinetic model was established and the regulation mechanism by which CTAC interacts with clay mineral surfaces was revealed for rare earth leaching process enhanced by CTAC. The results indicate that the appropriate amount of CTAC can increase the permeation velocity by 1.16×10 −4 cm·s −1 . Moreover, the rare earth leaching rate increased from 83.75 % to 95.65 %, accompanied by a reduction in leaching equilibrium time under optimal conditions. However, a higher concentration of CTAC results in a lower permeation velocity due to the increasing viscosity and the hydrophilicity. The relatively low pH will affect permeability of composite leaching agent in the ore pillar, diminishing its beneficial impact on rare earth leaching. The kinetic equation, fitted by the shrinking core model, suggests that the leaching adheres to an internal diffusion control mechanism, underscoring mass transfer as the pivotal limiting factor in rare earth leaching. CTAC reduces surface tension and viscosity, facilitating the permeation of the leaching solution into the rare earth ore. Furthermore, CTAC can be adsorbed on the surface of rare earth mineral particles, increasing the contact angle of clay minerals, elevating the Zeta potential, and diminishing the thickness of the diffusion layer, thus promoting mass transfer during leaching. The results of atomic force microscopy (AFM) analysis shows that the appropriate amount of CTAC adsorbed on rare earth ores can decreases the thickness of the hydration film on the particles' surface, further improving the mass transfer efficiency during the leaching process. The findings of this study offer new insights into the green and efficient extraction of rare earth resources from both theoretical and technical perspectives.

Rare Earth Extraction with lonquest® 801 initial modelling development

Fast Extraction and Enrichment of Rare Earth Elements from Waste Water Via Microfluidic-Based Hollow Droplet

Liquid-liquid extraction of rare earth elements using systems that are more environmentally friendly: Advances, challenges and perspectives

Leaching of Rare Earths from End-of-Life NdFeB Magnets with Citric Acid Using Full Factorial Design, Response Surface Methodology, and Artificial Neural Network Analysis

Leaching process assisted by cetyltrimethylammonium chloride for weathered crust elution-deposited rare earth ores: Leaching behavior, kinetic analysis and interfacial regulation

Efficient Extraction and Stripping of Nd(III), Eu(III) and Er(III) by Membrane Dispersion Micro-Extractors

A microfluidic study of synergic liquid-liquid extraction of rare earth elements.

An eco-friendly and high-yield extraction of rare earth from the leaching solution of ion adsorbed minerals

Selective Extraction of Rare Earth Elements from Monazite Ores with High Iron Content

Fundamental Principle and Practices of Solvent Extraction (SX) and Supported Liquid Membrane (SLM) Process for Extraction and Separation of Rare Earth Metal(s)

Effective extraction of rare earth elements from ion-adsorption type rare earth ore by three bioleaching methods

Recovery of Rare Earths from Nitric Acid Leach Solutions of Phosphate Ores Using Solvent Extraction with a New Amide Extractant (TODGA)

Efficient Enrichment and Recovery of Rare Earth Elements with Low Concentration by Membrane Dispersion Micro-Extractors

Scientific substantiation and development of innovative processes for the extraction of zirconium and rare earth elements in the deep and comprehensive treatment of eudialyte concentrate

A Novel Process for Recovering Rare Earth from Weathered Black Earth

The enrichment and separation of lanthanides ions from wastewater using solvent sublation coupled with high speed countercurrent chromatography

Development and optimization of high-performance extraction chromatography method for separation of rare earth elements

Optimization of rare earth magnet recovery processes using oxalic acid in precipitation stripping: Insights from experimental investigation and statistical analysis

Recovery of Rare Earth Elements from Mining Tailings: A Case Study for Generating Wealth from Waste

Extraction and separation of rare earth elements using LN resins in hydrochloric acid

Efficient Recovery and Enrichment of Rare Earth Elements by a Continuous Flow Micro-Extraction System