Abstract:Ultra-high-performance concrete (UHPC) is a new type of high-performance cement-based composite. It is widely used in important buildings, bridges, national defense construction, etc. because of its excellent mechanical properties and durability. Freeze thaw and salt erosion damage are one of the main causes of concrete structure failure. The use of UHPC prepared with multi-walled carbon nanotubes (MWCNTs) is an effective method to enhance the durability of concrete structures in complex environments. In this work, the optimal mix proportion based on mechanical properties was obtained by changing the content of MWCNTs and water binder ratio to prepare MWCNTs UHPC. Then, based on the changes in the compressive strength, mass loss rate, and relative dynamic modulus of elasticity (RDME), the damage degree of concrete under different salt erosion during 1500 freeze-thaw (FT) cycles was analyzed. The changes in the micro pore structure were characterized by scanning electron microscope (SEM) and nuclear magnetic resonance (NMR). The test results showed that the optimum mix proportion at the water binder ratio was 0.19 and 0.1% MWCNTs. At this time, the compressive strength was 34.1% higher and the flexural strength was 13.6% higher than when the MWCNTs content was 0. After 1500 salt freezing cycles, the appearance and mass loss of MWCNTs-UHPC prepared according to the best ratio changed little, and the maximum mass loss was 3.18%. The higher the mass fraction of the erosion solution is, the lower the compressive strength and RDME of concrete after FT cycles. The SEM test showed that cracks appeared in the internal structure and gradually increased due to salt freezing damage. However, the microstructure of the concrete was still relatively dense after 1500 salt freezing cycles. The NMR test showed that the salt freezing cycle has a significant influence on the change in the small pores, and the larger the mass fraction of the erosion solution, the smaller the change in the proportion of pores. After 1500 salt freezing cycles, the samples did not fail, which shows that MWCNTs UHPC with a design service life of 150 years has good salt freezing resistance under the coupling effect of salt corrosion and the FT cycle.

Resilient crystalline admixture in ultra-high performance self-healing concrete under cyclic freeze-thaw with de-icing salts

Durability of micro-cracked UHPC subjected to coupled freeze-thaw and chloride salt attacks

Assessment of impact resistance recovery in Ultra High-Performance Concrete through stimulated autogenous self-healing in various healing environments

Self-healing Properties of Lightweight High-Toughness Cementitious Composites under Dry-Wetting Cycles

Containment of internal expansion caused by alkali-aggregate reaction with ultra-high performance fiber reinforced concrete

Systematic studies on behaviors of ultra-high performance concrete subject to freezing and thawing cycles combining DIC technology

Sustainable ultra-high performance concrete with incorporating mineral admixtures: Workability, mechanical property and durability under freeze-thaw cycles

Autogenous self-healing of engineered cementitious composites under freeze-thaw cycles

Bacteria-based self-healing concrete exposed to frost salt scaling

High temperature and freeze-thaw study of strengthened concrete with ultra-high-performance concrete

Multi-performance experimental assessment of autogenous and crystalline admixture-stimulated self-healing in UHPFRCCs: Validation and reliability analysis through an inter-laboratory study

Investigation of Microstructural Damage in Ultrahigh-Performance Concrete under Freezing-Thawing Action

Effect of matrix self-healing on the bond-slip behavior of micro steel fibers in ultra-high-performance concrete

Experimental Study on the Salt Freezing Durability of Multi-Walled Carbon Nanotube Ultra-High-Performance Concrete

A review on autogenous self-healing behavior of ultra-high performance fiber reinforced concrete (UHPFRC)

Development of cementitious capillary crystalline waterproofing agents and durability study of concrete in the presence of chloride with sulfate in aqueous environment

Performance evaluation of fresh-to-fresh cast SCC/ECC and SCC/UHPC composites under the coupling effect of freeze-thaw and deicing solution

Experimental research on durability of high-performance synthetic fibers reinforced concrete: Resistance to sulfate attack and freezing-thawing

Study on Frost Resistance and Interface Bonding Performance through the Integration of Recycled Brick Powder in Ultra-High-Performance Concrete for Structural Reinforcement

Investigation into the Effects of Crystalline Admixtures and Coatings on the Properties of Self-Healing Concrete

Transport Properties and Resistance Improvement of Ultra-High Performance Concrete (UHPC) after Exposure to Elevated Temperatures