Abstract:In this study, Mg-modified sludge biochar (MB) and Mg-Fe double oxides/sludge biochar composites (MFB) were synthesized for enhanced removal of phosphate from aqueous solution. The phosphate adsorption followed the Langmuir-Freundlich isotherm model, and the maximum capacity was 142.31 mg P/g and 35.41 mg P/g for MB and MFB, respectively. MB exhibited the higher adsorption capacity at pH 8–9 and performed well under the influences of coexisting anions and temperature (4–45 °C). Adsorption kinetics was well described by the pseudo-second-order kinetic model, indicating the chemical bonding between phosphate and adsorption sites. The adsorption capacity of phosphate decreased by < 15% after three successive recycles. Based on FTIR, XRD, and XPS analysis, the main mechanisms for phosphate removal by MB included electrostatic attraction, surface complexation, and precipitation. Hydroxides/oxides particles of Mg on the surface of MB with positive charge could adsorb HPO42− and PO43− to form surface complex and convert to MgHPO4 and Mg3(PO4)2. The released amounts of Fe, Cd, Cr, Pb, Cu, Zn, Sb, and As from MB and MFB were low and acceptable. However, the released amount of Mg was as high as 4.9 wt% for MB and 8.7 wt% for MFB at the pH corresponding maximum adsorption capacity, posing a risk of salt increase. The grass (Lolium perenne L.) germination and early growth with the addition of P-laden biochars as fertilizer are seriously inhibited due to the high alkalinity, particularly for MB. The environmental risk of P-laden biochars (with high alkalinity and salt content) as fertilizer should be emphasized in practical application.

Enhanced removal efficiency of nitrogen and phosphorus from swine wastewater using MgO modified pig manure biochar

Enhanced heavy metal stabilization and phosphorus retention during the hydrothermal carbonization of swine manure by in-situ formation of MgFe2O4

Magnesium-modified biochar was used to adsorb phosphorus from wastewater and used as a phosphorus source to be recycled to reduce the ammonia nitrogen of piggery digestive wastewater

A novel chitosan modified magnesium impregnated corn straw biochar for ammonium and phosphate removal from simulated livestock wastewater

Optimization of pig manure-derived biochar for ammonium and phosphate simultaneous recovery from livestock wastewater

Regulating bacterial dynamics by Mg-modified biochar addition to mitigate gaseous emissions during pig manure composting

Effects of Added Calcium-Based Additives on Swine Manure Derived Biochar Characteristics and Heavy Metals Immobilization

Preparation and application of MgO-loaded tobermorite to simultaneously remove nitrogen and phosphorus from wastewater

Enhanced nitrogen and phosphorus adsorption performance and stabilization by novel panda manure biochar modified by CMC stabilized nZVZ composite in aqueous solution: Mechanisms and application potential

Treatment of Piggery Wastewater Using Multi-Soil-layering System

Recovery of Phosphorus From Swine Manure by Ultrasound/H2O2 Digestion, Struvite Crystallization, and Ferric Oxide Hydrate/Biochar Adsorption

Synergistic effects of CO2 and MgCl2 on heavy metals removal and phosphorus recovery in biochar obtained from pyrolysis of swine sludge

Resource utilization of swine sludge to prepare modified biochar adsorbent for the efficient removal of Pb(II) from water

Adsorption of phosphate over a novel magnesium-loaded sludge-based biochar

Magnesium doped biochar for simultaneous adsorption of phosphate and nitrogen ions from aqueous solution

Effect of corn pre-puffing on the efficiency of MgO-engineered biochar for phosphorus recovery from livestock wastewater: mechanistic investigations and cost benefit analyses

Enhanced removal of phosphate from aqueous solution using Mg/Fe modified biochar derived from excess activated sludge: removal mechanism and environmental risk

Simultaneous adsorption of ammonia nitrogen and phosphate on electro-assisted magnesium/aluminum-loaded sludge-based biochar and its utilization as a plant fertilizer

MgO-modified biochar for the removal of dissolved humus from water and its potential application as a fertilizer

MgO-loaded nitrogen and phosphorus self-doped biochar: High-efficient adsorption of aquatic Cu2+, Cd2+, and Pb2+ and its remediation efficiency on heavy metal contaminated soil

Pretreatment of Biogas Slurry by Modified Biochars to Promote High-Value Treatment of Wastewater by Microalgae