Abstract:The high temperature compressive characteristics of relatively light weight AlCoCrFeNi HEA were investigated via compression tests in a wide deformation temperature (T) range of 1073–1373 K and strain rate (ε˙) range of 10−3–1 s−1. Hot deformation led to the phase constitution transformation from the disorder BCC (A2) + order BCC (B2) at the room temperature to FCC + A2+ B2 +σ at 1073 K and 1173 K, and then to FCC + A2+B2 phase at 1273 K and 1373 K. The kinetic analysis was performed based on the flow stress data by using the hyperbolic sine law constitutive models with a higher the correlation coefficient (R2). Using combination of kinetics analysis and microstructure evolution results, it can be concluded that there was a gradual transformation of the dominant deformation mechanism from the symbiosis effects of grain boundary sliding (GBS) in fine grains and local dislocation gliding in coarse grains at 1073 K to the dislocation climbing mechanisms at 1373 K. The flow stress decreased with the decreasing strain rate and/or increasing true strain, as well as the deformation temperature. At 1073 K and 1173 K, the flow softening was primarily associated with the GBS of ultrafine dynamic recrystallization (DRX) grains in the local phase transformation regions, as well as the dynamic precipitation of FCC phases. While, the softening effect was primarily controlled by the dynamic precipitation of FCC phases and dynamic recovery (DRV) at 1273 K. When the deformation temperature rose to 1373 K, the main softening mechanisms were the continuous DRX (CDRX) and DRV, as well as the coarsening and dissolution of A2 phases Moreover, the clear serration behaviors at 1373 K/1s−1 and 1373 K/10−3s−1 were induced by the interaction effect between the dislocation and cluster.

Hot compression behaviors and microstructure evolutions of a cast dual-phase NiCoFeCrAl0.7 high-entropy alloy

Hot compression behaviors and microstructure evolutions of a cast dual-phase NiCoFeCrAl<sub>0.7</sub> high-entropy alloy

Experimental Investigation and Crystal Plasticity Modelling of Dynamic Recrystallisation in Dual-Phase High Entropy Alloy During Hot Deformation

Flow Behavior and Microstructures of Powder Metallurgical Crfeconimo0.2 High Entropy Alloy During High Temperature Deformation

Dynamic impact behavior and deformation mechanisms of Cr(26)Mn(20)Fe20Co(20)Ni(14) high-entropy alloy

Microstructural Evolution and Elevated-Temperature Strengthening Mechanism of Co-free FeCrMnNiV0.2Alx High-Entropy Alloys During Annealing

Unique hot deformation behavior and microstructure evolution of a dual FCC-phase CoCrCu1.2FeNi high entropy alloy

Mechanical properties and microstructure of the Al0.3CoCrFeNiTi0.3 high entropy alloy under dynamic compression

Hot deformation behavior of Ni61Fe10Cr10Al17Mo2 high-entropy alloy with hierarchical structure

Microstructure Evolution of FeCrNiMn Duplex High Entropy Alloys During High-Temperature Compression

High temperature deformation mechanism and microstructural evolution of relatively lightweight AlCoCrFeNi high entropy alloy

Unleashing the microstructural evolutions during hot deformation of as-cast AlCoCrFeNi 2.1 eutectic high entropy alloy

Hot deformation behavior and dynamic recrystallization of dual-phase (CrCoNi)94Al3Ta3 medium entropy alloy

FeCoNiCr 0.5 Al x High-Entropy Alloys with Dual-Phase Solidification Microstructure and High Compressive Properties

On the Room-Temperature Tensile Deformation Behavior of a Cast Dual-Phase High-Entropy Alloy CrFeCoNiAl0.7

Hot Compression Behavior of a Novel High Entropy Alloy

Microstructure Evolution and Mechanical Properties of an Annealed Dual-Phase CrFeCoNiAl0.7 High-Entropy Alloy

High temperature deformation behavior of dual-phase Al0.6CoCrFeNi high-entropy alloys

Hot Deformation Behavior and Microstructure Evolution of Annealed CrFeCoNiAl 0.1 High Entropy Alloy

Hot deformation characteristics and microstructure evolution of Al20Co36Cr4Fe4Ni36 eutectic high entropy alloy

Multiscale-phase-driven strength-ductility synergy in Fe3Cr2CoNiAlx high entropy alloys