Highly dispersed Cu atoms in MOF-derived N-doped porous carbon inducing Pt loads for superior oxygen reduction and hydrogen evolution

Chao Wang,Long Kuai,Wei Cao,Harishchandra Singh,Alexei Zakharov,Yuran Niu,Hongxia Sun,Baoyou Geng

DOI: https://doi.org/10.1016/j.cej.2021.130749

IF: 15.1

2021-12-01

Chemical Engineering Journal

Abstract:<p>The preparation of oxygen reduction reaction (ORR) and hydrogen evolution reaction (HER) catalysts with high activity, stability and low platinum loading has always been the focus of research. The single-atom platinum supported catalyst greatly improves the utilization of platinum, but the catalytic activity and selectivity are greatly affected by the platinum coordination environment, and the preparation of the material is difficult. Doping base metals to adjust the electronic structure of platinum is an effective strategy to improve catalyst performance. In this work, copper-platinum alloy nanoparticles were loaded on N-doped porous carbon via a targeted route guided by highly dispersed Cu atoms derived from MOF. The product C-ZIF-CuPt has high activity and high stability ORR, HER bifunctional catalytic performance, which is better than commercial Pt/C (20 wt%). The Pt activity in C-ZIF-CuPt is 4.4 times (ORR) and 6.7 times (HER) than Pt/C. Spectromicroscopic determinations unveiled that strong interactions between carbon carrier and the CuPt alloys contribute to the overall stabilities. DFT calculations show that Cu doping can increase the d-band center of Pt, reduce the ORR overpotential, and the activation energy barrier to water molecules, which is beneficial to ORR and HER catalysis. Under the same carrier conditions, the performance of sub-nano (single atoms, clusters) platinum-supported catalysts (C-ZIF-Cu-Pt) is inferior to C-ZIF-CuPt. This further shows that platinum alloying can effectively improve the performance of the catalyst.</p>

engineering, chemical, environmental

What problem does this paper attempt to address?

The main problems that this paper attempts to solve are to develop oxygen reduction reaction (ORR) and hydrogen evolution reaction (HER) catalysts with high activity, high stability and low platinum loading. Specifically, the paper mentions that although single - atom platinum - based catalysts can significantly improve the utilization efficiency of platinum, their catalytic activity and selectivity are greatly affected by the platinum coordination environment, and the material preparation is more difficult. In addition, single - atom platinum catalysts are prone to agglomeration and oxidation, which affects the activity and stability of the catalysts. Therefore, the paper proposes a method of preparing copper - platinum alloy nanoparticles by introducing copper atoms into nitrogen - doped porous carbon in order to improve the performance of the catalysts.

The paper verifies the efficient dispersion of copper - platinum alloy nanoparticles on nitrogen - doped porous carbon and their catalytic effects on ORR and HER through experiments and theoretical calculations. The results show that the activity of the prepared C - ZIF - CuPt catalyst in ORR and HER is 4.4 times and 6.7 times that of the commercial Pt/C catalyst respectively, while maintaining high stability. These results indicate that the formation of copper - platinum alloy by the introduction of copper atoms can effectively improve the performance of the catalysts, reduce the amount of platinum used, thereby reducing costs and increasing application potential.