Abstract:Although the development of disinfection technologies with novel mechanisms has stagnated, we demonstrate the bactericidal effects and mechanisms of high-speed nanodroplet generation technology. The first development of this technology in 2017 gushes out a water droplet of 10 nm in size at 50 m/s; however, the target surface does not become completely wet. Nanodroplets were exposed to biofilm models of Staphylococcus aureus, Pseudomonas aeruginosa, Escherichia coli, and Serratia marcescens. This phenomenon was verified when the nanodroplets collide with the surface of the bacteria at an impact pressure of ~75 MPa. S. aureus was exposed to nanodroplets for 30 seconds at 75 MPa, which exploded the bacterial body and completely sterilized. Eighteen MPa damaged the bacterial surface, causing peptidoglycan leakage. S. aureus was repaired and survives in this state. In contrast, in Gram-negative bacteria, nanodroplets with 18 MPa penetrated some biofilm-forming bacteria but did not hit all of them, and the viable count was not significantly reduced. Although all three bacterial species were completely sterilized at 75 MPa, the disinfectant effect was affected by the biomass of the biofilm formed. In summary, our findings prove that nanodroplets at 18 MPa on the bacterial surface were ineffective in killing bacteria, whereas at 75 MPa, all four bacterial species were completely sterilized. The disinfection mechanism involved a high-velocity collision of nanodroplets with the bacteria, physically destroying them. Our results showed that disinfection using this technology could be an innovative method that is completely different from existing disinfection techniques. Importance: Although existing disinfection techniques demonstrate bactericidal effects through chemical reactions, concerns regarding human toxicity and environmental contamination have been raised. To the best of our knowledge, this study is the first in the world to reveal that the use of this technology, with nanodroplets of less than 100 nm, can destroy and sterilize bacterial cells by colliding with biofilm-forming bacteria at 75 MPa. Furthermore, because this technology uses only water, it can solve the problems of human toxicity and environmental contamination caused by existing disinfection techniques. Because of its minimal water usage, it can be employed for sanitation worldwide without being limited to specific regions. Our report proposes an unprecedented physical disinfection approach that utilizes a high-speed nanodroplet generation technology.

Bactericidal Efficacy of So-Called Sanitizers in Japan

Inactivation Mechanism of Escherichia Coli Induced by Slightly Acidic Electrolyzed Water.

Comparing the antibacterial efficacy and functionality of different commercial alcohol-based sanitizers

[Analysis of bactericidal material generated by electrical devices advertising bactericidal ability against bacteria on the agar gel plates]

Comparison of Various Disinfectants on Bactericidal Activity Under Organic Matter Contaminated Environments

Oil-Based Sanitization in Low-Moisture Environments: Delivery of Acetic Acid with Water-in-Oil Emulsions

Efficacy of disinfectants on control and clinical bacteria strains at a zonal referral hospital in Mwanza, Tanzania: a cross sectional hospital-based study

The efficacy of commercial decontamination agents differs between standardised test settings and research laboratory usage for a variety of bacterial species

A Meta-Analysis and Systematic Review of Listeria monocytogenes Response to Sanitizer Treatments

Impact of Interfering Substances on the Bactericidal Efficacy of Different Commercially Available Hypochlorous Acid-Based Wound Irrigation Solutions Commonly Found in South-East Asia

Impact of high-speed nanodroplets on various pathogenic bacterial cell walls

The Efficacy of Common Household Cleaning Agents for SARS-CoV-2 Infection Control

Comparison of Ion Plasma, Vaporized Hydrogen Peroxide, and 100% Ethylene Oxide Sterilizers to the 12/88 Ethylene Oxide Gas Sterilizer

Prevalence of alcohol-tolerant and antibiotic-resistant bacterial pathogens on public hand sanitizer dispensers

[Evaluation of the antimicrobial activity of products used for disinfection of work surfaces in the food industry]

Efficacy of Ozone to Reduce Bacterial Populations in the Presence of Substance of Citrus Fruits

Evaluation of calcium hydroxide, calcium hypochlorite, peracetic acid, and potassium bicarbonate as citrus fruit sanitizers

Comparative evaluation of disinfectant efficacy against biofilm-residing microorganisms

Anti-microbial efficacy of a scientifically developed and standardized herbal-alcohol sanitizer

Inactivation of Multiple Human Pathogens by Fathhome's Dry Sanitizer Device: Rapid and Eco-Friendly Ozone-Based Disinfection

Evaluation of pyrogens remaining on reusable medical devices after washing and sterilization