Abstract:The interfacial behavior of surfactants exerts a considerable impact on the chemical flooding-produced liquid treatment project. For circumventing the limitations of model simplification and single-factor simulation of previous molecular dynamics (MD) studies, this paper based on the experimental results of crude oil-phase and water-phase composition constructed different simulation systems of "crude oil/SDBS/mineral water" considering the concentration of sodium dodecyl benzene sulfonate (SDBS). The impact of SDBS concentration on the stability of the crude oil–mineral water interfacial film was explored, and the simulation results were verified by comparing with the simulation system of "crude oil/SDBS/pure water" and interfacial tension experiments. The simulated results showed that the SDBS molecules in the system exist in the form of a monolayer film after dynamic relaxation equilibrium, and with the increase in concentration, the number of SDBS molecules per unit area of the film increases, and the molecular chain bending characteristics are weakened. The order of the effect of inorganic cations on the aggregation degree of SDBS is Ca2+ > Na+ > K+ > Mg2+. When the concentration of SDBS increased from 0.15 to 0.70 mol/L, the total oil water interfacial film thickness increased from 1.433 nm in the crude oil/SDBS/mineral water system and 1.272 nm in the crude oil/SDBS/pure water system to 2.125 nm in the crude oil/SDBS/mineral water system and 2.398 nm in the crude oil/SDBS/pure water system. The absolute value of interface formation energy increased from 1223.59 and 1236.32 to 2739.19 and 3033.64, respectively, which are also basically consistent with the experimental results of interface tension. Furthermore, inorganic ions will weaken the performance of the surfactant SDBS and detrimentally affect the structural strength and stability of interfacial films. These results offer useful insights into the stabilization mechanism of oil–water emulsions. In particular, they provide a basis for the design and optimization of new pathways for oil–water emulsion instability in oilfield development.This article has not yet been cited by other publications.

Effect of Surface Freezing of Sodium Hexadecyl Sulfate - Hexadecanol Mixed Adsorbed film on OW Emulsion Stability

Surface freezing of cationic surfactant-adsorbed films at the oil-water interface: Impact on oil-in-water emulsion and pickering emulsion stability

Immobilizing Water into Crystal Lattice of Calcium Sulfate for Its Separation from Water-in-Oil Emulsion.

Effect of Freeze-Thaw Treatment on the Precipitation of Octyl β-D-Galactoside Hemihydrate Crystal from the Aqueous Solution

Surface Tension, Interfacial Tension and Emulsification of Sodium Dodecyl Sulfate Extended Surfactant

Thermodynamically stable structure of hydroxy alkane sulfonate surfactant monomers in water achieving high water solubility and a low CMC

Long-Term Thermal Stability of Ionic Surfactants for Improving Oil Production at High-Salinity High-Temperature Conditions

Study of Interfacial Properties of Hydroxyl Sulfobetaine Surfactant

Impact of Sodium Dodecyl Benzene Sulfonate Concentration on the Stability of the Crude Oil–Mineral Water Interfacial Film: A Molecular Dynamics Simulation Study

Investigations of interfacial heat transfer and phase change on bioinspired superhydrophobic surface for anti-icing/de-icing

Interactions Between Colliding Oil Drops Coated with Non-Ionic Surfactant Determined Using Optical Tweezers

Molecular Dynamics Study on Performance of Olefin Sulfonate at the Decane–Water Interface: Effect of Molecular Architecture

Temperature-dependent Phase Transition and Desorption Free Energy of Sodium Dodecyl Sulfate at the Water/vapor Interface: Approaches from Molecular Dynamics Simulations.

Comparative Studies On The Crystalline To Fluid Phase Transitions Of Two Equimolar Cationic/Anionic Surfactant Mixtures Containing Dodecylsulfonate And Dodecylsulfate

Isothermal Titration Calorimetric Analysis on Solubilization of an Octane Oil-In-Water Emulsion in Surfactant Micelles and Surfactant-Anionic Polymer Complexes

Electric surface potential of dodecane nano-drops in aqueous solutions of low ioinic strength

Stability of the emulsion during the injection of anionic and cationic surfactants in the presence of various salts

Stability of n‐hexadecane phase change material emulsions using sugar‐based surfactants and the HLD platform

Highly Persistent and Robust Emulsion Stabilized by Hierarchical Cellulose Microgel through Stereo-hindrance under Extreme Conditions

Effect of a Cationic Surfactant on Droplet Wetting on Superhydrophobic Surfaces.

Adsorption behavior of oil-displacing surfactant at oil/water interface: Molecular simulation and experimental