Abstract:Characterizing the propensity of molecules to distribute between fluid phases is key to describing chemical concentrations in heterogenous mixtures and the corresponding physiochemical properties of a system. Usually, partitioning is studied under equilibrium multiphase conditions. However, there are situations where a mixture may form only a single phase at equilibrium but can exist in multiple phases when out-of-equilibrium. Emulsion droplets, such as oil-in-water droplets stabilized by surfactant, are one such example. Droplets are often thermodynamically unstable and persist under non-equilibrium conditions for some time while disappearing by dissolution or solubilization over longer timescales. Consequently, equilibrium properties like partition coefficients or interfacial tensions may not necessarily describe the properties of an out-of-equilibrium droplet. Here, the partitioning of nonionic surfactants between microscale oil droplets and water is investigated under non-equilibrium conditions wherein the droplets shrink in volume over time via solubilization and only a single phase exists at equilibrium. Quantitative mass spectrometry is used to analyze the composition of individual micro-droplets as a function of time under conditions of varying surfactant composition, concentration, and oil molecular structure. Common nonionic surfactants partition into oil micro-droplets within minutes and reach a non-equilibrium steady state concentration that can be orders of magnitude higher than the aqueous phase. Over timescales of hours, the droplet solubilizes and sheds accumulated surfactant back into the water. Transiently high concentrations of oil and surfactant accumulate near the oil droplet - water interface over time, which leads to the localized evolution of a microemulsion phase and unexpectedly low interfacial tension. The introduction of an ionic surfactant that forms mixed micelles with the nonionic surfactant reduces the nonionic surfactant transfer into oil. Based on this observation, we use stimuli-responsive ionic surfactants to trigger phase separation and mixing inside binary oil droplets via modulation of the nonionic surfactant partitioning. This study thus reveals generalizable non-equilibrium states and conditions experienced by solubilizing droplets that govern emulsion properties.

Isothermal Titration Calorimetric Analysis on Solubilization of an Octane Oil-In-Water Emulsion in Surfactant Micelles and Surfactant-Anionic Polymer Complexes

Solubilization of Octane in Cationic Surfactant–anionic Polymer Complexes: Effect of Ionic Strength

Solubilization of Octane in Electrostatically-Formed Surfactant-Polymer Complexes

The Transition from Vesicles to Micelles Induced by Octane in Aqueous Surfactant Two-Phase Systems

Probing oppositely charged surfactant and copolymer interactions by isothermal titration microcalorimetry

Synergistic mechanism in anionic/zwitterionic and anionic/nonionic surfactant mixtures on improving the thermal stability of emulsions: An experimental and simulation study

Surface Tension, Interfacial Tension and Emulsification of Sodium Dodecyl Sulfate Extended Surfactant

Critical Micellar Concentrations of Quaternary Ammonium Surfactants with Hydroxyethyl Substituents on Headgroups Determined by Isothermal Titration Calorimetry

Oil solubilization in sodium dodecylbenzenesulfonate micelles: New insights into surfactant enhanced oil recovery

Molecular Dynamics Study on Performance of Olefin Sulfonate at the Decane–Water Interface: Effect of Molecular Architecture

Thermodynamically stable structure of hydroxy alkane sulfonate surfactant monomers in water achieving high water solubility and a low CMC

Dynamic partitioning of surfactants into non-equilibrium emulsion droplets

Variation of micellization, thermodynamic, and surface properties of sodium dodecyl sulfate in aqueous media using 1,3-disulfo-2-alkyl imidazolium chloride ionic liquids

Study of inclusion complexes of cycloamylose with surfactants by isothermal titration calorimetry

Stabilization of Water-In-Octane Nano-Emulsion. Part I: Stabilized by Mixed Surfactant Systems

Molecular Simulations on the Coalescence of Water-in-Oil Emulsion Droplets with Non-ionic Surfactant and Model Asphaltene.

Interfacial and micellization behavior of binary mixture of amino sulfonate amphoteric surfactant and octadecyltrimethyl ammonium bromide: Effect of short chain alcohol and its chain length

Experimental and DFT studies on micellization features of anionic surface active ionic liquid and nonionic surfactant mixtures: Effect of imidazolium cations

Cloud point, auto-coacervation, and nematic ordering of micelles formed by ethylene oxide containing carboxylate surfactants

A molecularly informed field-theoretic study of the complexation of polycation PDADMA with mixed micelles of sodium dodecyl sulfate and ethoxylated surfactants

The effects of nonionic surfactants on enhancing miscibility between oil and CO 2 : A molecular dynamics study