[Screening for chronic kidney disease in patients with diabetes mellitus].

P. Kes,N. Bašić-Jukić,V. Furić-Čunko

Liječnički vjesnik

Abstract:

What problem does this paper attempt to address?

Impact of deep-fat frying cycles on the physicochemical characteristics of two edible vegetable oils marketed in Algeria

Farida Benmeziane,Khawla Araba,Amina Belahcene

DOI: https://doi.org/10.51745/najfnr.8.17.21-31

2024-02-12

The North African Journal of Food and Nutrition Research

Abstract:Background: Vegetable oils containing polyunsaturated fatty acids are prone to oxidation when exposed to high-temperature frying processes. Aims: This study aims to follow the changes that occur in frying oil when used to fry potatoes. Material and Methods: The impact of the ratio of potatoes (g) to oil (g) as well as the number of frying cycles on the quality of two commonly marketed oils in Algeria: 100% soybean oil (oil A) and a blend of 60% soybean, 20% sunflower, and 20% corn oil (oil B) was assessed. The quality of these oils throughout repeated frying cycles was monitored by analyzing pH, density, color, moisture, acidity, peroxide value, saponification value, and acid index. Results: The results of the present study revealed that both oils experienced deterioration as the frying cycles were repeated, with more significant degradation observed with the 1/5 ratio of fries to oil compared to the 1/8 ratio. Remarkably, the 100% soybean oil deteriorated more rapidly than the oil blend. Conclusion: Based on the observed changes in physicochemical parameters and chemical indices, the use of frying oils beyond the third cycle significantly compromises their quality and safety. This not only impacts the consumer’s health but also the organoleptic properties of fried foods. Therefore, it is highly recommended to refrain from exceeding this limit to ensure optimal frying practices and protect consumer health. Keywords: Vegetable oils, deep-fat frying, ratio of fries/volume of oil, physical quality, chemical indices.
Antioxidant activity of selected plants extract for palm oil stability via accelerated and deep frying study

Welela Meka Kedir,Abiyot Kelecha Geletu,Getabalew Shifera Weldegirum,Milkesa Fanta Sima

DOI: https://doi.org/10.1016/j.heliyon.2023.e17980

IF: 3.776

2023-07-07

Heliyon

Abstract:Antioxidants are organic compounds that help to prevent lipid oxidation and improve the shelf-life of edible oils and fats. Currently, synthetic antioxidants were used as oil stabilizing agent. However, synthetic antioxidants have been causing various health risks. As a result, natural antioxidants such as most parts of olive plant, green tea, sesame, medicinal plants were plays an important role to retard lipid oxidation. The palm oil was continuously frying at 180 °C for 6 days using Lepidium sativum (0.2%w/v) and Aframomum corrorima (0.3%w/v) seeds extracts as antioxidant. The physicochemical properties of oil in the herbal extract additive group significantly maintained the oil quality during frying compared to the normal control and the food sample containing group. The L. sativum extract had a greater oil stability compared to A. corrorima extract. However, the frying oil without herbal extract significantly increase the physicochemical properties of oil such as iodine value, acid value, free fatty acid, total polar compounds, density, moisture content, pH etc. during repetitive frying. The antioxidant activity of the plant extract was outstanding, with an IC50 value in the range of 75-149.9 μg/mL when compared to the standard butyl hydroxy anisole, which had an IC50 value in the range of 74.9 ± 0.06-96.7 ± 0.75 μg/mL. The total phenolic and flavonoid content of the extract for L. sativum was 128.6 ± 0.00 mg GAE/g, 127.0 ± 0.00 mg QE/g, and 130.16 ± 0.001 mg GAE/g, 105.76 ± 0.02 mg QE/g, respectively. The significant effect of the plant extract on the degradation of oil and the formation of free fatty acids was confirmed by Fourier transform infrared spectroscopy. The result of these study revealed that the ethanolic crude extract of L. sativum and A. corrorima had a potential natural antioxidant to prevent the degradation of palm oil.
Deep-fat Frying of Vegetable Oils: Major Chemical Reactions and Effect of Natural Extracts on Oxidative Stability - A Review

T. M. Nanayakkara,W. A. G. E. Wijelath,T. M. M. Marso

DOI: https://doi.org/10.4038/sljae.v2i2.40

2020-12-28

Sri Lankan Journal of Agriculture and Ecosystems

Abstract:Deep-fat frying is a popular cooking technique in the world and vegetable oil is widely used as the frying medium in this process. Deep-fat frying produces both desirable and undesirable compounds through various chemical reactions. Undesirable chemical compounds are formed mainly through hydrolysis, oxidation and polymerization reactions. These compounds lower the oxidative stability thereby, the quality of oil and food. Antioxidants are added to improve the oxidative stability of oil during deep-fat frying by lowering the free radical action in frying oil. Even though artificial antioxidants are added to frying oils to lower the effects of undesirable chemical reactions and their products, the efficiency of artificial antioxidants decrease with increasing temperature and may cause adverse health effects to the consumer. Natural extracts of rosemary (Rosmarinus officinalis), sage (Salvinia officinalis), tea (Camelia sinensis), oregano (Origanum vulgare) and barley (Hordeum vulgare) are stable under frying conditions and act as effective antioxidants during deep-fat frying. Despite confirmation by numerous research, the use of natural compounds as antioxidants in deep-fat frying is not popular in the food industry. Hence this review explores the major chemical reactions in vegetable oils during deep-fat frying and the effect of natural compounds and extracts in interrupting these undesirable chemical reactions.
Investigation of the Physicochemical Properties of Vegetable Oils Blended with Sesame Oil and Their Oxidative Stability during Frying

Fereshteh Ramroudi,Seyed Ali Yasini Ardakani,Arefeh Dehghani-tafti,Elham Khalili Sadrabad

DOI: https://doi.org/10.1155/2022/3165512

2022-03-30

International Journal of Food Science

Abstract:To investigate the antioxidant activity and physicochemical properties of oil, sunflower (SFO) and corn oil (CO) and their combinations with sesame oil (SO) were prepared. The analyses of fatty acid composition (GC-FID), oxidative stability index (Rancimat), smoke point, and antioxidant activity (DPPH) were done on oil samples. Then, the frying process in presence of potato chips was done for 3 days at 180°C. Oil samples were gathered after each frying cycle and chemical analysis (peroxide value, free fatty acid, p-anisidine value, TOTOX, total polar content, TBARS, and conjugated diene and triene) was measured. The major fatty acid composition of oil samples was linoleic acid, oleic acid, palmitic acid, and stearic acid. The OSI of oil samples was reported as CSO > SSO > SO > CO > SFO . The smoke point of all samples was in the standard limit. The SFO with 266.50°C had the highest smoke point. The antioxidant activity of samples was reported as SO > CSO > CO > SSO > SFO . The IC50 of SO was 52.17 mg/g which was higher than other samples. The result of frying indicated that prolonged heating process would increase the thermal oxidation. It was shown that oils blended with SO had good stability during deep frying. Therefore, blending oil with SO is considered as an economic approach to improve the oil oxidation stability.
Effect of Deep Frying of Potatoes and Tofu on Thermo-Oxidative Changes of Cold Pressed Rapeseed Oil, Cold Pressed High Oleic Rapeseed Oil and Palm Olein

Małgorzata Wroniak,Marianna Raczyk,Bartosz Kruszewski,Edyta Symoniuk,Dominika Dach

DOI: https://doi.org/10.3390/antiox10101637

IF: 7.675

2021-10-18

Antioxidants

Abstract:One of the commonly used food preparation methods is frying. Fried food is admired by consumers due to its unique taste and texture. Deep frying is a process of dipping food in oil at high temperature, usually 170–190 °C, and it requires a relatively short time. The aim of this study was to analyze the thermo-oxidative changes occurring during the deep frying of products such as potatoes and tofu in cold pressed rapeseed oils and palm olein. Cold pressed rapeseed oil from hulled seeds (RO), cold pressed high oleic rapeseed oil from hulled seeds (HORO), and palm olein (PO) (for purposes of comparison) were used. Characterization of fresh oils (after purchase) and oils after 6, 12, and 18 h of deep frying process of a starch product (potatoes) and a protein product (tofu) was performed. The quality of oils was analyzed by determining peroxide value, acid value, p-anisidine value, content of carotenoid and chlorophyll pigments, polar compounds, smoke point, color (CIE L*a*b*), fatty acids content and profile, calculation of lipid nutritional quality indicators, and oxidative stability index (Rancimat). Cold pressed high oleic rapeseed oil was more stable during deep frying compared to cold pressed rapeseed oil, but much less stable than palm olein. In addition, more thermo-oxidative changes occurred in the tested oils when deep frying the starch product (potatoes) compared to the deep frying of the protein product (tofu).

biochemistry & molecular biology,chemistry, medicinal,food science & technology
Effect of natural extracts on the stability of sunflower oil and acrylamide formation at different thermal treatments

E. A. El-Naggar,E. El-Naggar

DOI: https://doi.org/10.21608/aasj.2018.30446

2018-12-01

Archives of Agriculture Sciences Journal

Abstract:This study was conducted to reduce the simulated chemical changes of sunflower oil during intermittent heating and / or frying model technique, and to improve the thermal stability of oil, and to study the effects on acrylamide formation level by some additives such as oleoresin thyme (OTE) and rosemary extracts (ORE) at different levels (100, 200, 300, 400, 500 and 600 mg-1L oil), in comparison to standard oil sample (without addition of extracts) and / or (with addition 200 mg-1L oil of BHA), and the chemical changes were correlated with acrylamide content aiming at establishing prediction models for estimating acrylamide content; during intermittent heating and / or frying model technique of potato chips at 175o C for 24 hrs. at three consecutive days (8 hrs. daily). The results could be concluded that addition of OTE and/ or ORE to sunflower oil kept its characteristics from being deteriorated. During the simulated heating and / or frying model technique, the OTE or ORE act as an antioxidant taking part in the chain radical oxidation, as well as simultaneously inhibiting the thermal processes occurring in oil. Induction period (IP) was decreasedby increasing the thermal treatment period. Moreover, the addition of OTE and/ or ORE up to 400 mg-1L oil increase IP before thermal treatment then slows down the decreasing of the IP in comparison to the control samples, and TPCs, TBA and acrylamide content of control oil samples were significantly lower than that of the oil samples treated with OTE and/or ORE.Under the conditions simulated heating and / or frying model technique, the OTE inhibits oxidative processes more strongly than ORE or BHA. The results demonstrate that the heating model technique causes a slower increase in acrylamide content during treatment at 175o C in comparison to frying model technique, (39.18 %) under heating model technique.While, ORE reduced the acrylamide ranged by 25.54% and 27.48% fewer than500 mg-1L oil during frying and heating model technique respectively. The correlation coefficient between acrylamide level and frying time was very high (r = 0.986) for control sample, and an equation for prediction the acrylamide was γ = -190.9 + 0.116 X. The correlation coefficient between acrylamide level and TPCs content was very high (r = 0.994) for control sample, while the correlation coefficient between acrylamide level and TPCs (r = -0.621) for oil treated with OTE at 400 mg-1L during frying, and (r = 0.732) during heating model system.During the progressive frying of the potato chips, the sensory panel could distinguish a difference in flavor between the fried potato chips in sunflower oil with and without OTE or ORE. Panelists preferred the chips fried in oil treated with OTE or ORE.
Synergistic effect of Lipophilic Antioxidants Extracted from Cloves (Syzygium aromaticum) with Vitamin E on the Stability of Cotton Seed Oil during Frying of Plantain Chips

Fabrice Tonfack Djikeng,Serge Eric Ngangoum,Aduni Ufuan Achidi,Ophelie Leonce Bidias à Koul,Erika Audrey Eyoum Alima,Bernard Tiencheu

DOI: https://doi.org/10.9734/afsj/2022/v21i230409

2022-03-12

Asian Food Science Journal

Abstract:Aims: This study was conducted in order to evaluate the synergistic effect of the ethanolic extract and powder of cloves buds (Syzygium aromaticum) with vitamin E in delaying cotton seed oil oxidation during frying of plantain chips. Study design: Purchase of clove buds, cleaning, preparation of clove buds ethanolic extract and powder, supplementation of cotton seed oil enriched with vitamin E with the extract and powder at different concentrations and evaluation of oil stability during frying of plantain chips. Place and Duration of Study: General Science Laboratory, School of Agriculture and Natural Resources, Catholic University Institute of Buea-Douala Campus, Littoral Region, Cameroon, from January to June 2019. Methodology: In refined cotton seed oil (2.5 L) containing vitamin E as preservative was respectively added 0.30, 0.60, 1.00 and 1.30% of Syzygium aromaticum (SA) buds ethanolic extract and 0.5, 1, 1.50% of buds powder. After ensuring the good dispersion of the antioxidants added, oil samples were used for the deep-frying of plantain chips for 10 and 20 min respectively. Oil sample without clove served as control. The stability of the various oil samples was evaluated through the determination of peroxide, thiobarbituric acid, iodine and acid acid (% oleic) values. Results: Results showed that the natural plant extract and powder increased the stability of the oil compared to the control. Oil samples supplemented with the extract at concentration 0.30 and 0.60% presented good stability compared to the control, while the same extract at higher concentrations (1.00 and 1.30%) tend to behave as prooxidant. Concerning the powder it exhibited better good preservative properties on the oil and at all levels. Conclusion: Clove ethanolic extract at concentration < 0.60% and its powder at concentration 0.50-1.5% can be used to delay cotton seed oil alteration during frying of plantain chips.
Quality investigation of the most consumed refined seed oils after French fries’ domestic short-term deep-frying process

Sarah Moura de Oliveira,Taís Andreza Batista de Jesus,Ketily Alves Lariú,Carla Gabrielle da Silva de Jesus,Emília Akil

DOI: https://doi.org/10.55905/oelv22n3-189

2024-03-27

Abstract:Deep-frying is an attractive food preparation method and has been in use for centuries. It is a very popular culinary practice worldwide and can be used both industrially and domestically. Deep-fried food has a unique sensorial property, such as flavor, aroma, and texture. However, the chemical quality of the frying oil can be affected by the high temperatures normally used in deep-frying. Complex series of reactions that occur in vegetable oils during deep-frying (hydrolytic and oxidative rancidity processes) they are related to several mechanisms, such as reactive species, chemical composition of the lipid, environment, and process, influencing the speed and nature of the oxidative process. This paper aimed to analyze the quality of the vegetable oils most consumed by the population (refined soybean and sunflower oils) used in domestic short-term deep-frying process, using a domestic-grade electric fryer and a conventional method. French fries were used because they are a convenient product, highly consumed in industrialized countries. Domestic events of short-term deep-frying were carried out for three days, with one-week intervals. After each frying events, the refined oils were analyzed. Methodology consists in bromatological analyses of quality research applying analyzes of acidity and peroxide, in which the free acidity content, compounds formed by hydrolytic rancidity, and hydroperoxides content, the first compounds formed in the oil ́s oxidative rancidification process, were analyzed. These parameters will be fundamental in oils oxidative evaluating during frying. According to the results, fresh vegetable oils samples remained within regulatory limits. However, after short-term deep-frying, free fatty acids and hydroperoxides content increased in both domestic short-term deep-frying using both vegetable oils, exception of sunflower oil after last day of frying. Additionally, there was no significant difference in the fatty acids value increase comparing with both domestic frying techniques. However, there was significant difference in hydroperoxide value comparing the oils between deep-frying techniques. However, in general even the oils have shown great thermal quality, bromatological analyses demonstrated that must be taken careful when reusing oils for short-term deep-frying. Seeing that the electric fryer is effective in oil quality compared preservation comparing with conventional method, probably due to temperature control and better sealing efficiency.
Physical, Chemical and Sensory Characterization of Deep-Fried Fresh-Cut Potatoes Coated with Hydrocolloid/Herbal Extracts

Mia Kurek,Maja Repajić,Mario Ščetar,Lea Radošević,Sandra Pedisić,Zdenka Pelaić,Branka Levaj,Kata Galić

DOI: https://doi.org/10.17113/ftb.60.04.22.7691

Abstract:Research background: Recently, natural plant extracts have been used to increase the nutritional value of food and to potentially reduce the absorbed fat and the formation of acrylamide in fried foods. Literature data on the use of edible polymers with nettle or olive leaf extracts are scarce. Experimental approach: The effect of novel coatings on colour, fat absorption, phenolic and sugar content, and acrylamide formation in deep-fat-fried fresh-cut potatoes was evaluated. Extracts of olive and nettle leaves were incorporated in carboxymethyl cellulose (CMC) and gum arabic, used as coatings for potatoes and applied before frying. This aimed to improve the nutritional quality of deep-fat-fried fresh-cut potatoes. Results and conclusions: Enrichment of the edible coatings with extracts resulted in a significant change in the visible colour of the potatoes before frying. Significant effect of the extract amount on the sensory characteristics of potatoes was also observed. Most importantly, the perception of characteristic potato odour and taste was not significantly affected by the coating. Although higher amounts of the extract (1.5%) resulted in higher phenolic mass fraction in fried potatoes, the sensory scores decreased. After frying, fat mass fraction in the coated potatoes was reduced by about 15% compared to the uncoated samples. The type of extract affected the total sugar mass fraction in fried potatoes, which was lower in the samples with coatings enriched with olive leaf than in those with nettle leaf. Only gum arabic coating had a reducing effect on acrylamide mass fraction by 17%. Based on all the obtained results, CMC and gum arabic coatings did not influence sensory properties, so they can be recommended as carriers of functional compounds or as a frying pre-treatment for potatoes with favourable effect on fat and acrylamide content. Novelty and scientific contribution: The knowledge obtained in this study can be exploited for preparation of coatings with functional compounds used as a pre-treatment for fried food with favourable effect on fat and acrylamide content.
Performance of individual antioxidants and their blend during repeated frying of tortilla chips

Andrea García‐Pérez,José Enrique Muñoz-Hernández,Claudia Guzmán‐Corona,Abel Cerón‐García,César Ozuna,María Elena Sosa‐Morales

DOI: https://doi.org/10.1111/jfpp.14263

2019-10-22

Journal of Food Processing and Preservation

Abstract:The performance of palm olein (PO) with different antioxidants during the repeated frying of tortilla chips was analyzed. Butylated hydroxytoluene (BHT) at concentration of 200 mg/kg (primary synthetic antioxidant), ascorbyl palmitate (AP) at 100 mg/kg (secondary synthetic antioxidant), and their blend (in the same concentration than individual addition) were added. Dough included 2% sesame seed, as it is prepared in commercial formulations for tortilla chips in the Guanajuato region (Mexico). Dough was sheeted, cut, and baked. Batches of 0.08 kg of tortillas were deep fat fried at 190°C for 2 min to produce the chips. Chemical indices—such as peroxide value (PV) and free fatty acids (FFA)—color and viscosity of the POs were evaluated. After 20 batches, the values for PO + BHT were PV = 29.6 meq/kg, FFA = 0.19%; PO + AP had PV = 13.3 meq/kg and FFA = 0.27%; and PO + BHT+AP, PV = 11.81 meq/kg and FFA = 0.29%. The best performance—based on lower primary oxidation—was achieved with the blend of antioxidants. Practical applicationsRepeated frying with PO is a common operation for production of tortilla chips. The blend of primary (BHT) and secondary (AP) antioxidants at 200 and 100 mg/kg, respectively, is recommended for manufacturers of frying media and for food industry, since it improved the performance (lower primary oxidation) of PO. In this way, safer fried tortilla chips would be offer to consumers, avoiding risks for consumers' health (lower peroxide content) and having a product with good quality.

food science & technology
Efficacy of exogenous natural antioxidants in stability of polyunsaturated oils under frying temperature

Ali, M. Abbas

DOI: https://doi.org/10.1007/s11694-022-01601-0

2022-09-29

Abstract:The demand for plant source of polyunsaturated fatty acid (PUFA) is increasing due to the health concern over animal oils, but oxidation in PUFA-rich oils occurs rapidly during frying process. Under frying conditions, numerous reactions take place with the formation of degradative products which reduce nutritional quality and shelf-life of frying oil and fried foods. Using natural antioxidants instead of synthetic ones has been the tendency for retarding oil deterioration during frying. The chemical degradation of natural antioxidants during frying operation, seems to be the major pathway for antioxidant loss. This suggest to require a continuous modification to enhance their performances. In fact, much study was carried out on the activities of natural antioxidative agents at ambient or accelerated storage temperatures. The information on the fate of natural antioxidants at frying conditions is limited. Nevertheless, the need to develop a safe, potent, and stable natural antioxidative agent for frying operation still remains an appealing task. This review highlights the recent information on the performance of exogenous natural antioxidants in frying stability of polyunsaturated oils. The present investigations indicate that the stability is not just a function of individual components but may be a cumulative effect of various endogenous and exogenous antioxidants. Most of common antioxidants such as β-carotene, tocochromanols etc. may retard oxidative degradation during storage at lower temperature, they are less effective under frying conditions. Tocopherol, β-carotene and phenolic acids may form synergistic mixture. Under frying conditions, γ-oryzanol and phenolic compounds offer good protection of oils against oxidative deterioration.

food science & technology
Dynamic changes of fatty acids and related physical & chemical parameters during deep frying in fish oil supplemented blend oil

MA Feng-lan,CHEN Qi,ZHANG Lan,LI Duo

DOI: https://doi.org/10.3785/j.issn.1008-9209.2012.07.061

2012-01-01

Abstract:In recent years,China’s market has an novel edible oil-fish oil supplemented blend oil(FO),however,there is no data on its ability to be used for deep frying,how safe it is,and if it will produce a large number of transfatty acids,as well as how the dynamic changes of 20:5n-3and 22:6n-3during the frying process.The objective of the present study was to investigate the changes of fatty acids and other physical and chemical parameters in different doses of FO during deep frying.Two liters of soybean blend oil(SO),and 1.5%,3.0%,6.0%and 12.0% FO were used to fry fresh potato chips at the temperature of 180℃,respectively,for total 6days,each day frying 10times,each time frying 120g potato chips for 3minutes,and the interval of 5minutes between each frying.Oil was kept for 1.5hours at 180℃after daily deep frying.Gas liquid chromatography(GLC)was used to analyze the fatty acid composition(% of total fatty acid),and other physical and chemical parameters were determined according China National Standard(GB).The results showed that the main trans fatty acids(TFAs) produced during deep frying were t18 : 1,t18 : 2n6,t18 : 3n-6and t18 : 3n-3.The proportions of t18 : 1and t18 : 2n-6were increased with frying time,which was significantly higher in FO than that in SO.The proportion of t18 : 3n-6and t18 : 3n-3in 3.0%and 6.0% FO were increased in the first stage(0-12h),and then decreased.However,they were decreased in SO,1.5%and 12.0% FO with frying time.With the prolonging of the deep frying time,the proportions of 20 : 5n-3and 22 : 6n-3 decreased in different doses of FO,with 12.0% FO decreased most.After 4h,the acid value had a significant increasing trend;during 4-24h,acid value of SO was significantly lower than FO(P < 0.01).Anisidine value and polymer showed a similar trend with acid value.However,with the prolonging of the deep frying time,the peroxide value showed a rising trend,but overall peroxide value of SO was significantly higher than that of FO(P <0.01),which may be associated with antioxidant activity of 20 : 5n-3and 22 : 6n-3.In conclusion,FO and SO can be used for cooking safely,however,they are not suitable for long-term repeated deep frying.
Introducing degummed water‐extracted wild almond oil as a safe vegetable oil through the quality evaluation of par‐fried potato sticks and oil thermo‐oxidative stability during a continuous prolonged deep‐fat frying process

Niloufar Nekouei,Karamatollah Rezaei

DOI: https://doi.org/10.1002/fsh3.12019

2023-09-10

Food Safety and Health

Abstract:Abstract The purpose of this study is to evaluate the safety of degummed water‐extracted wild almond oil as a frying medium. Changes in the physicochemical properties of the oil as well as those of the fried potato sticks were evaluated over 10 h of frying at 180°C. Compared to a reference commercial frying oil, free fatty acid content, smoke point, anisidine value, conjugated dienes concentration, total polar compounds, color index, and viscosity did not change significantly during the frying process. French fries prepared during the 10 h of frying in the wild almond oil indicated lower fat levels than those prepared in the commercial frying oil. This can contribute to the well‐being of the consumers as well as to the cost‐efficiency of the process. The color indices are additional quality measures for the fried products that were similar for potatoes fried in both oil sources indicating the safe application of water‐extracted wild almond oil for frying purposes. The application of water‐extracted wild almond oil for frying purposes is found to be a safe process to consider in future frying applications.
Dual-Stage ultrasound in deep frying of potato chips; effects on the oil absorption and the quality of fried chips

Peyman Alikhani Chamgordani,Mahmoud Soltani Firouz,Mahmoud Omid,Nikoo Hadidi,Pouya Farshbaf Aghajani

DOI: https://doi.org/10.1016/j.ultsonch.2024.106779

IF: 9.336

2024-01-22

Ultrasonics Sonochemistry

Abstract:Potato chips are popular high-consuming ready-to-eat meals in all of the world which specially attract a lot of attention from youth and children. Reducing oil absorption and improving the quality of chips are major undertakings within the industry. This research aimed to find the best ultrasonic bath-based method by investigating the optimal ultrasonic pre-treatment and developing an ultrasound (US) assisted frying system (UAFS) to reduce the oil absorption of potato chips while maintaining an acceptable quality. Through this technique, the potato chips get sonicated during deep frying in hot oil. US-pretreatment at temperatures of 25 °C and 73 °C, along with US-assisted frying, resulted in the minimal amount of oil which may be due to the US creating potential pores during the pre-treatment phase, which then expand further during the subsequent sonication stage. UAFS in combination with US-pretreatment produced more crispy chips due to the fact that the texture of potato slices becomes more porous. UAFS resulted in a decrease in the moisture content of the fried chips attributed to an increase in the effective diffusion coefficient and mass. Pretreating the chips at 73 °C significantly reduce the color change producing brighter product by inactivation of enzymes such as polyphenol oxidase. Finally, the result of TOPSIS optimization based on potato chips properties confirms that US-pretreatment in 73 °C brine followed by frying using UAFS is the best approach. Scanning electron microscope (SEM) images of potato chips also support this issue.

chemistry, multidisciplinary,acoustics
Analysis of 8-oxooctanoate, 9-oxononanoate, fatty acids, oxidative stability, and iodine value during deep-frying of French fries in edible oils blended with palm oil

Yejin Choi,Dohyoung Lee,Jonggab Yim,Kwang-Geun Lee

DOI: https://doi.org/10.1007/s10068-024-01615-y

2024-06-24

Abstract:Four blended oils including palm + corn oil (PC), palm + grapeseed oil (PG), corn + grapeseed oil (CG), and palm + corn + grapeseed oil (PCG) were used as frying media. The 8-oxo and 9-oxo content, fatty acid composition, oxidative stability index, and iodine value of samples (n = 42) were analyzed. As the frying cycles increased, the content of 8-oxo and 9-oxo also increased significantly (p < 0.05) and showed the highest content of 965.56 ± 0.706 μg/g in 100 frying cycles of PCG. After 20-40 frying cycles in CG, the amount of palmitic, stearic, oleic and linoleic acid increased up to 15.5% (p < 0.05). The oxidative stability of palm oil was the highest at 16.76-18.33 h (p < 0.05). The iodine value of grapeseed oil was the highest at 144.96 ± 2.569-153.64 ± 2.233 g iodine/100 g oil (p < 0.05). Among the examined oils, PC was the most suitable alternative to palm oil.
Oil Uptake and Polycyclic Aromatic Hydrocarbons (PAH) in Fried Fresh-Cut Potato: Effect of Cultivar, Anti-Browning Treatment and Storage Conditions

Sandra Balbino,Maja Repajić,Tea Solarić,Draženka Dite Hunjek,Dubravka Škevin,Klara Kraljić,Marko Obranović,Branka Levaj

DOI: https://doi.org/10.3390/agronomy10111773

2020-11-13

Agronomy

Abstract:This work examined the influence of cultivar, anti-browning treatment, package atmosphere and storage duration on the oil uptake and polycyclic aromatic hydrocarbons (PAH) levels in fried fresh-cut potato (FCP). Birgit and Lady Claire potato slices were pre-treated with sodium chloride solution (1%) and sodium ascorbate solution (2%), packaged in vacuum and modified atmosphere and stored at 10 °C/8 days. Oil uptake was significantly higher in Birgit FCP and was not affected by minimal processing. HPLC analysis/fluorescence detection was able to identify a total of 14 PAH. Benzo(a)pyrene and ΣPAH4 levels (0.62 and 1.36 μg kg−1, respectively) were below the EU limits in all fried FCP samples. Majority of examined light and heavy PAH were higher in Lady Claire, while naphthalene, fluorene and pyrene were decreased by vacuum packaging. No differences in PAH levels were noted in FCP fried at the beginning and after 2, 4 and 8 days of storage.
Moringa oleifera Oil Nutritional and Safety Impact on Deep-Fried Potatoes

Silia Boukandoul,Farid Zaidi,Carla S P Santos,Susana Casal

DOI: https://doi.org/10.3390/foods12244416

IF: 5.2

2023-12-08

Foods

Abstract:Aiming to understand the nutritional impact of Moringa oleifera oil (MOO) on the quality of fried potatoes as consumed, a frying study using intermittent frying at 180 °C was conducted over 5 days, with a total heating time of 15 h, against olive (OO) and sunflower (SFO) oils. Additionally, due to MOO's higher costs, a SFO/MOO blend (80/20 w/w) was tested. With similar fat incorporation and moisture contents, potato lipid composition revealed the impact of oil oxidation over the frying time, gradually decreasing the content of unsaturated fatty acids and antioxidants, including vitamin E, carotenoids and ascorbic acid, and increasing the incorporation of trans fatty acids (TFAs) and volatile aldehydes. When the potatoes fried at the ninth hour of heating are compared, MOO and OO were still able to protect potato ascorbic acid better than SFO, due to the low oxidative stress imposed by their fatty-acid composition. SFO, on the contrary, with linoleic acid as the main fatty acid, and despite its higher content of vitamin E, demonstrated higher oxidative stress and increased incorporation of alkenals and alkadienals. Acrylamide content was generally low, as were the trans fatty acids formed and incorporated with frying time, with MOO fried potatoes having lower amounts of all these process contaminants. Interestingly, the blend SFO/MOO (80/20 w/w) doubled the amount of vitamin E in fried potatoes when compared with SFO alone, increased the ascorbic acid protection and reduced by half the amounts of volatile aldehydes, indicative of an efficient reduction of the oxidative status of the SFO-fried potatoes, with benefits to the consumer from a health point of view.
Comparative Analysis of Frying Performance: Assessing Stability, Nutritional Value, and Safety of High-Oleic Rapeseed Oils

Zhenglin Zhou,Pan Gao,Yuan Zhou,Xingye Wang,Jiaojiao Yin,Wu Zhong,Martin J T Reaney

DOI: https://doi.org/10.3390/foods13172788

IF: 5.2

2024-09-01

Foods

Abstract:Frying is a critical process in the food industry, where selecting appropriate vegetable oils is key to achieving optimal results. In this study, French fries were fried at 175 °C with five different oils, the changes in the physicochemical indexes and free radical scavenging rate of the oils during the frying process were investigated, and the most suitable oils for frying were identified through comparative analysis using principal component analysis (PCA). We assessed the frying performances of hot-pressed high-oleic-acid rapeseed oil (HHRO), cold-pressed high-oleic-acid rapeseed oil (CHRO), soybean oil, rice bran oil, and palm oil utilizing principal component analysis over an 18 h period. The HHRO and CHRO showed lower acid values (0.31, 0.26 mg/g), peroxide values (2.09, 1.96 g/100 g), p-anisidine values (152.48, 178.88 g/mL), and total polar compound percentages (27.60%, 32.10%) than other oils. Furthermore, both the HHRO and CHRO demonstrated enhanced free radical scavenging abilities, indicative of their higher antioxidant capacities, as corroborated by the PCA results. Benzopyridine, 3-monochloropropane-1,2-diol ester, squalene, tocopherols, and polyphenol from the HHRO and CHRO during frying were compared. A comprehensive examination of harmful substances versus nutrient retention during frying revealed that the HHRO contained fewer hazardous compounds, while CHRO retained more nutrients. Therefore, this study analyzes the oxidation regulation of HHRO in frying applications, highlights the prospects of HHRO for frying in terms of health and economy, and contributes valuable insights for informed vegetable oil selection within the food industry.
Oxidation and Thermal Degradation of Oil during Frying: A Review of Natural Antioxidant Use

Maxwell D. Erickson,Dmytro P. Yevtushenko,Zhen-Xiang Lu

DOI: https://doi.org/10.1080/87559129.2022.2039689

IF: 6.0435

2022-04-10

Food Reviews International

Abstract:Frying foods in hot vegetable oil is an efficient and convenient method for food preparation that imbues the product with qualities that are desirable to consumers. During the process of frying, the heated oil cooks the food, but the high temperatures also promote the damaging oxidation and degradation reactions that decrease oil quality over time. In order to prevent these reactions, antioxidants have been added to fryer oil to extend its life. Synthetic antioxidants are typically added to fryer oil, however there is growing concern about their long-term effects on human health. Therefore, finding natural alternatives is an important area of research. This paper reviews the current research around using natural antioxidants to delay the decrease of oil quality under frying conditions.

food science & technology,nutrition & dietetics
Analysis of oxidation products and toxic compounds in edible and blended oil during the deep-frying of french fries

Mingi Chu,Eunjeong Noh,Kwang-Geun Lee

DOI: https://doi.org/10.1007/s10068-023-01494-9

2024-01-17

Abstract:This study sought to analyze the oxidative products [acid value (AV), free fatty acids (FFA), conjugated dienoic acid (CDA), p-anisidine value (p-AV), antioxidant-prooxidant balance (APB) value] and toxic compounds [3-monochloropropane diol (3-MCPD), glycidyl ester (GE)] in edible oils after deep-frying. The deep-frying edible oils evaluated herein included soybean oil (S), palm oil (P), canola oil (C), grape seed oil (G), and a 1:1 blend (SC, SG, PC, PG, and CG). As frying time increased, the level of AV in PC, total FFA contents in CG, and p-AV in CG significantly increased up to 200%, 45.5%, and 410.5%, respectively (p < 0.05). The levels of 3-MCPD, and GE were 0.81-6.28 µg/mL and 0.14-2.84 µg/mL, respectively. The levels of 3-MCPD, GE, CDA, and APB changed significantly as frying time increased. Analysis of the correlation between oxidation products and toxic compounds indicated that the contents of 3-MCPD and palmitic acid were positively correlated. Supplementary information: The online version contains supplementary material available at 10.1007/s10068-023-01494-9.

[Screening for chronic kidney disease in patients with diabetes mellitus].

Impact of deep-fat frying cycles on the physicochemical characteristics of two edible vegetable oils marketed in Algeria

Antioxidant activity of selected plants extract for palm oil stability via accelerated and deep frying study

Deep-fat Frying of Vegetable Oils: Major Chemical Reactions and Effect of Natural Extracts on Oxidative Stability - A Review

Investigation of the Physicochemical Properties of Vegetable Oils Blended with Sesame Oil and Their Oxidative Stability during Frying

Effect of Deep Frying of Potatoes and Tofu on Thermo-Oxidative Changes of Cold Pressed Rapeseed Oil, Cold Pressed High Oleic Rapeseed Oil and Palm Olein

Effect of natural extracts on the stability of sunflower oil and acrylamide formation at different thermal treatments

Synergistic effect of Lipophilic Antioxidants Extracted from Cloves (Syzygium aromaticum) with Vitamin E on the Stability of Cotton Seed Oil during Frying of Plantain Chips

Quality investigation of the most consumed refined seed oils after French fries’ domestic short-term deep-frying process

Physical, Chemical and Sensory Characterization of Deep-Fried Fresh-Cut Potatoes Coated with Hydrocolloid/Herbal Extracts

Performance of individual antioxidants and their blend during repeated frying of tortilla chips

Efficacy of exogenous natural antioxidants in stability of polyunsaturated oils under frying temperature

Dynamic changes of fatty acids and related physical & chemical parameters during deep frying in fish oil supplemented blend oil

Introducing degummed water‐extracted wild almond oil as a safe vegetable oil through the quality evaluation of par‐fried potato sticks and oil thermo‐oxidative stability during a continuous prolonged deep‐fat frying process

Dual-Stage ultrasound in deep frying of potato chips; effects on the oil absorption and the quality of fried chips

Analysis of 8-oxooctanoate, 9-oxononanoate, fatty acids, oxidative stability, and iodine value during deep-frying of French fries in edible oils blended with palm oil

Oil Uptake and Polycyclic Aromatic Hydrocarbons (PAH) in Fried Fresh-Cut Potato: Effect of Cultivar, Anti-Browning Treatment and Storage Conditions

Moringa oleifera Oil Nutritional and Safety Impact on Deep-Fried Potatoes

Comparative Analysis of Frying Performance: Assessing Stability, Nutritional Value, and Safety of High-Oleic Rapeseed Oils

Oxidation and Thermal Degradation of Oil during Frying: A Review of Natural Antioxidant Use

Analysis of oxidation products and toxic compounds in edible and blended oil during the deep-frying of french fries