Abstract:Direct measurement and control of the dynamic wetting properties of a lipid-coated water-air interface over a wide range of surface tension variations have many important applications. However, the wetting dynamics of the interface near its partial-to-complete wetting transition has not been fully understood. Here, we report a systematic study of the wetting dynamics of a lipid-coated water-air interface around a thin glass fiber of diameter 1-5 μm and length 100-300 μm. The glass fiber is glued onto the front end of a rectangular cantilever to form a "long-needle" atomic-force-microscope probe. Three surface modifications are applied to the glass fiber to change its wetting properties from hydrophilic to hydrophobic. A monolayer of phospholipid dipalmitoylphosphatidylcholine (DPPC) is deposited on the water-air interface in a homemade Langmuir-Blodgett trough, and the surface tension γL of the DPPC-coated water-air interface is varied in the range of 2.5 ≲ γL ≲ 72 mN/m. From the measured hysteresis loop of the capillary force for the three coated fiber surfaces with varying γL, we observe a sharp transition from partial to complete wetting when γL is reduced to a critical value (γL)c. The obtained values of (γL)c are 27 ± 1 mN/m for a DPPC-coated fiber surface and 23 ± 1 mN/m for an trichloro(1H,1H,2H,2H-perfluorooctyl) silane (FTS)-coated surface. Below (γL)c, the contact angle θ0 of the liquid interface is found to be zero for both hydrophobic fiber surfaces and the corresponding spreading parameter S becomes positive. For the FTS-coated fiber surface, the height of capillary rise exhibits a jump when γL is reduced to (γL)c, which indicates that a rapidly advancing liquid film is formed on the fiber surface when the partial-to-complete wetting transition takes place. Our experiment thus establishes a quantitative method by which many other liquid interfaces coated with polymers, surfactants, and biomolecules (such as proteins and lipids) may be characterized dynamically.

Experiment of contact angle hysteresis of a droplet on hydrophobic fibrous membrane

Experiment of droplet contact angle hysteresis on PTFE fibrous membrane in pore-scale

Apparent Contact Angle and Contact Angle Hysteresis on Liquid Infused Surfaces

Sliding Friction and Contact Angle Hysteresis of Droplets on Microhole-Structured Surfaces

Exploring Contact Angle Hysteresis Behavior of Droplets on the Surface Microstructure

Wetting Dynamics of a Lipid Monolayer

Understanding contact angle hysteresis on an ambient solid surface

Experiment of droplet anisotropic wetting behavior on micro-grooved PDMS membranes

An analytical approach for determining contact angle hysteresis on smooth, micropillared, and micropored homogeneous surfaces

Droplet hysteresis investigation on non-wetting striped textured surfaces: A lattice Boltzmann study

Dynamic contact angle hysteresis in liquid bridges

Friction of Droplets Sliding on Microstructured Superhydrophobic Surfaces.

A Linear Regime of Hysteresis for Calculating the Dynamic Contact Angle under Low Capillary Numbers with Displacement Experiments in Microscale PDMS Microchannels

Lattice Boltzmann Modeling of Drying of Porous Media Considering Contact Angle Hysteresis

Wetting and Contact-Angle Hysteresis: Density Asymmetry and van der Waals Force

Analysis of Water Droplet Motion on Hydrophobic Surfaces with Different Microstructures

Contact angle hysteresis of cylindrical drops on chemically heterogeneous striped surfaces

Fabrication of Super-hydrophobic Surfaces for Microfluidic Chips

Dynamic contact angle measurement of hydrophilic open microchannels: The role of surface wettability

Measuring surface tensions of soft solids with huge contact-angle hysteresis

Numerical simulation of droplet dispersion within meso-porous membranes