Abstract:This study was conducted in order to examine the impact of magnetite (Fe3O4), a conductive material capable of promoting direct interspecies electron transfer (DIET) among microorganisms, on the efficiency of anaerobic digestion in a plug flow reactor (PFR) using food wastewater (FW) as the substrate. The effects of recovering and replenishing magnetite discharged along with the digestate during continuous operation of the PFR were also evaluated. A PFR with a total volume of 17 L was utilized as the reactor for anaerobic digestion. The inoculum was obtained from Icheon Biogas Research Facility, which operated with a mixture of pig slurry and FW in a 7:3 (w/w) ratio. FW was used as the substrate (volatile solids (VS) content of 85,865 mg-VS/L). The PFR was set for operation at 39 °C, and after a stabilization period of approximately 82 days, the hydraulic retention time (HRT) was set at 40 days. The study was conducted in three stages: stage 1 (83~122 days), stage 2 (123~162 days), and stage 3 (163~202 days). For the maintenance of an organic loading rate of 2.12 kg-VS/m3/d, 0.3 L/d of substrate was added every 24 h, and analysis of an equal amount of discharged digestate was performed. The experimental treatments included a control without the addition of magnetite after the stabilization period, treatment (T1) with addition of magnetite (20 mM in digestate) and subsequent recovery and replenishment of magnetite on the discharge of digestate, and treatment (T2) with addition of magnetite (20 mM) without the replenishment of magnetite. Analytical parameters included the characteristics of the discharged digestate (pH, NH4+-N, chemical oxygen demand (CODCr), total volatile fatty acids (TVFAs), and alkalinity), and methane production (Mp). During the period of operation of the PFR after the stabilization period, no significant differences in pH and NH4+-N, based on the recovery and replenishment of magnetite, were observed, and a stably functioning PFR was observed. However, in stage 2, due to the increased degradation of organic matter caused by DIET, the CODCr of T1 and T2 decreased by 9.42% compared with the control. In stage 3, the magnetite content in the reactor in T2 decreased by a maximum of 9.42% compared to T1. In stage 3, the Mp for T2 was similar to that of the control, with a maximum discharge of magnetite of 3.06%, and the Mp decreased by 5.40% compared to T1. Regarding the ratio of methanogens in the community, the results of an analysis of the digestate from stage 3 showed an increase in the community of acetotrophic methanogens, specifically Methanosarcina. The findings of this study confirm that DIET was effectively promoted by maintaining the concentration of 20 mM magnetite in the PFR while using FW as a substrate.

Magnetite encapsulated in carbon shell particles (Fe3O4@C) to boost anaerobic methanogenesis of chloramphenicol wastewater

Uncovering the mechanisms of ethanol stimulation on magnetite-enhanced anaerobic process treating oxytetracycline contained wastewater

Enhancing Electron Transfer by Ferroferric Oxide During the Anaerobic Treatment of Synthetic Wastewater with Mixed Organic Carbon

Effect of Magnet-Fe3O4 composite structure on methane production during anaerobic sludge digestion: Establishment of direct interspecies electron transfer

Target the Enhancement of DIET-Based CO2-Dependent Methanogenesis Via Synergy of Magnetite Addition and Inorganic Carbon Recirculation

Synergistic effect of extracellular polymeric substances and carbon layer on electron utilization of Fe@C during anaerobic treatment of refractory wastewater

Enhancing Electron Transfer by Magnetite During Phenanthrene Anaerobic Methanogenic Degradation

Long-term and multiscale assessment of methanogenesis enhancement mechanisms in magnetite nanoparticle-mediated anaerobic digestion reactor

Enhancement of anaerobic treatment of antibiotic pharmaceutical wastewater through the development of iron-based and carbon-based materials: A critical review

Magnetite drives self-dechlorination of 4-chlorophenol in anoxic aquatic sediments

Metaproteomics analysis of anaerobic digestion of food waste by the addition of calcium peroxide and magnetite

Enhanced Anaerobic Digestion of Long Chain Fatty Acid by Adding Magnetite and Carbon Nanotubes

A Short-Term Stimulation of Ethanol Enhances the Effect of Magnetite on Anaerobic Digestion

Evaluating the stability and performance of a novel core-shell ZVI@C-montmorillonite particle for anaerobic treatment of chloramphenicol wastewater

Optimization of dry anaerobic co-fermentation of sludge and corn straw with magnetite (Fe3O4)

Synergistic enhancement of microbes-to-pollutants and inter-microbes electron transfer by Fe, N modified ordered mesoporous biochar in anaerobic digestion

Magnetite Nanoparticles Enhance the Performance of A Combined Bioelectrode-Uasb Reactor for Reductive Transformation of 2,4-Dichloronitrobenzene

Effects of Magnetite (Fe3O4) as an Electrical Conductor of Direct Interspecies Electron Transfer on Methane Production from Food Wastewater in a Plug Flow Reactor

Enhanced Anaerobic Wastewater Treatment by a Binary Electroactive Material: Pseudocapacitance/Conductance-Mediated Microbial Interspecies Electron Transfer.

Magnetite Nanoparticles and Carbon Nanotubes for Improving the Operation of Mesophilic Anaerobic Digesters

Effects of magnetite on nitrate-dependent anaerobic oxidation of methane in an anaerobic membrane biofilm reactor: Metatranscriptomic analysis and mechanism prediction