Abstract:Gas and dust posed a threat to the safe working environment of miners. The key to the effectiveness of coal seam water injection in controlling gas and dust was the wetting of the coal body by water. The gas displacement characteristics were crucial for evaluating the wetting effect of coal. To investigate gas displacement characteristics during the water wetting process of gas-bearing coal, this study employed an experimental equipment of water wetting gas-bearing coal to test the gas displacement quantity under varying gas pressure conditions, and the microscopic influence mechanism was revealed. During the water wetting gas-bearing coal, there was an increase in the accumulated displacement gas quantity corresponding to rising adsorption equilibrium pressures, whereas the accumulated displacement gas rate decreased. Water wetting progressively reduced the system's Helmholtz free energy, reaching a minimum at equilibrium, indicative of a balanced wetting state. The displacement gas quantity curve initially rose linearly, reflecting rapid infiltration, then curved upwards more gradually as gravity and viscosity slowed the process, until reaching a relatively stable state. The curve mirrored the coal's saturation progression. The molecular formula of anthracite was C123H58N2O5. Elemental compositions of carbon, hydrogen, oxygen, and nitrogen matched elemental analysis results. The bridge carbon ratio of this molecular model was aligning with the bridge carbon ratio ascertained from the 13C NMR spectrum analysis. Above the coal-water interface, the relative concentration of water molecules increased with the increase of gas pressure. However, below the coal and water interface, the relative concentration of water molecules increased with the decrease of gas pressures. As the gas pressure increased, the adsorption degree of water molecules weakened, the degree of gas displacement in coal decreased, the diffusion coefficient of methane molecules decreased, the dispersion degree of water molecules increased, the aggregation degree weakened, and the diffusion coefficient of water molecules increased. The study results laid a theoretical foundation for revealing the mechanism of coal seam water injection wetting gas-bearing coal, achieving collaborative gas disaster prevention and pre-wetting dust reduction.

Study on the Water Absorption Characteristics of Anthracite Particles after Immersion in Water

Imbibition behavior of water on coal surface and the impact of surfactant

Experimental study of wetting effect of surfactant based on dynamic wetting process and impedance response of coal

An investigative and simulative study on the wetting mechanism of alkaline dust suppressant acting on long-flame coal

Study on the mechanism of the influence of surfactant alkyl chain length on the wettability of anthracite dust based on EDLVO theory and inverse gas chromatography

Study on Spontaneous Combustion Characteristics and Microstructure of Bituminous Coal under Water Immersion

Study on Pore Structure Change Characteristics of Water-Immersed and Air-Dried Coal Based on SEM-BET

The Influence of Water Immersion on the Physical and Chemical Structure of Coal

The Changing of Micromechanical Properties of Coal after Water Immersion: The Insight from Nanoindentation Test

Gas displacement characteristics during the water wetting process of gas-bearing coal and microscopic influence mechanism

Water Adsorption Characteristics of Coal with Different Particle Sizes: Experimental and Modeling Analyses

Molecular mechanism study on the effect of nonionic surfactants with different degrees of ethoxylation on the wettability of anthracite

Experimental investigation on the impact of water immersion time and particle size on the ignition characteristics of coal dust

Effect of water immersion on active functional groups and characteristic temperatures of bituminous coal

Surface physical properties and its effects on the wetting behaviors of respirable coal mine dust

The influence of long-time water intrusion on the mineral and pore structure of coal

An Experimental Study on Wetting of Coal Dust by Surfactant Solution

Study on dust reduction characteristics and mechanism of softened mine water

Effect of water intrusion on the characteristics of surface morphology and pore fracture spaces in argillaceous meagre coal

Quantitative characterization of water transport and wetting patterns in coal using LF-NMR and FTIR techniques

Experimental Study on the Wettability of Coal with Different Metamorphism Treated by Surfactants for Coal Dust Control