Optimizing the Utilization of Steel Slag in Cement-Stabilized Base Layers: Insights from Freeze–Thaw and Fatigue Testing

Peng-Cheng Song,Guo-Xin Chen,Ying-Jie Chen
DOI: https://doi.org/10.3390/ma17112576
IF: 3.4
2024-05-28
Materials
Abstract:This paper presents a study on the mechanical properties of cement-stabilized steel-slag-based materials under freeze–thaw cycles for a highway project in Xinjiang. Using 3D scanning technology the specimen model conforming to the real steel slag shape was established. The objectives of the study are as follows: to explore the sensitivity between the macro- and micro-parameters of the specimen and to establish a non-linear regression equation; and to study the changes in mechanical properties of materials under freeze–thaw cycles, fatigue loading, and coupled freeze–thaw cycle–fatigue loading. The results show that there are three stages of compression damage of the specimen, namely, linear elasticity, peak plasticity, and post-peak decline. Maximum contact forces between cracks and particles occur mainly in the shear zone region within the specimen. The compression damage of the specimen is a mixed tensile–shear damage dominated by shear damage. When freeze–thaw cycles or fatigue loads are applied alone, the flexural strength and fatigue life of the specimens show a linear relationship of decline. The decrease in flexural modulus at low stress is divided into the following: a period of rapid decline, a relatively smooth period, and a period of fracture, with a tendency to change towards linear decay with increasing stress. In the case of freeze–thaw–fatigue coupling, the flexural modulus of the specimen decreases drastically by about 50% in the first 2 years, and then enters a period of steady decrease in flexural modulus in the 3rd–5th years.
materials science, multidisciplinary,chemistry, physical,physics, applied, condensed matter,metallurgy & metallurgical engineering
What problem does this paper attempt to address?
### Problems the Thesis Aims to Solve This thesis aims to study the mechanical properties of cement - stabilized steel slag materials under freeze - thaw cycles in an expressway project in Xinjiang. Specifically, the objectives of the thesis are as follows: 1. **Explore the sensitivity between macroscopic and microscopic parameters of specimens**: Establish a non - linear regression equation to reveal the relationships between these parameters. 2. **Study the changes in mechanical properties of materials under freeze - thaw cycles, fatigue loading, and the coupling effect of freeze - thaw cycles and fatigue loading**: Through experiments and numerical simulations, analyze the damage and performance changes of materials under different conditions. ### Background and Significance - **Utilization problems of steel slag**: With the increase in steel production, the accumulation of steel slag has become an important problem faced by steel enterprises. The utilization rate of steel slag in Chinese steel enterprises is less than 20%, which not only wastes land resources but may also lead to serious environmental pollution and safety problems. - **Physical and mechanical properties of steel slag**: Steel slag has good hardness, crushing value and abrasion resistance value, and can partially or completely replace the aggregates in the mixture, thereby alleviating the shortage of construction resources and reducing environmental damage. - **Deficiencies in existing research**: At present, research on the application of steel slag in road engineering mainly focuses on being mixed into aggregates as an additive, while research on its application as a whole aggregate in road engineering is relatively scarce, especially in seasonal freeze - thaw conditions, and research on roads under the coupling effect of freeze - thaw cycles and fatigue loads is even more limited. ### Research Methods - **Experimental materials**: Use ordinary portland cement and steel slag aggregates, and test their physical and mechanical properties and chemical compositions through experiments. - **Mix proportion design**: According to Chinese specifications, select steel slag mixtures with different cement contents for compaction tests to determine the optimal water content and maximum dry density. - **Specimen preparation**: Fabricate cylindrical and beam - shaped specimens for unconfined compressive strength tests, freeze - thaw cycle tests, flexural strength tests and fatigue tests respectively. - **Numerical simulation**: Adopt 3D scanning technology to construct a real - shape model of steel slag particles, and use discrete element software for numerical simulation to analyze the mechanical responses of materials under different conditions. ### Main Innovation Points 1. **Freeze - thaw cycle research**: Conduct freeze - thaw cycle research on cement - stabilized steel slag mixtures (CSS) using all steel slag aggregates, and design the number of freeze - thaw cycles according to local climatic conditions. 2. **3D scanning technology**: Use 3D scanning technology to construct a real - shape model of steel slag particles, and calibrate the detailed parameters of the discrete element numerical model through unconfined compressive strength tests. 3. **Simulation of flexural strength and modulus changes**: Use simulated beam specimens to conduct flexural strength tests of materials under different numbers of freeze - thaw cycles, and realize the simulation of flexural modulus changes under the coupling of freeze - thaw cycles and fatigue loading. ### Conclusion Through experiments and numerical simulations, the thesis reveals the change laws of the mechanical properties of steel slag under freeze - thaw cycles and fatigue loading, providing a reference for the application of steel slag in road construction in cold regions.