Abstract:The effect of morphology of the long-period stacking ordered (LPSO) phase on mechanical properties of the Mg-7Gd-3Y-1Nd-1Zn-0.5Zr (wt.%) alloy have been studied. The results reveal that the block-like 14H-LPSO phases in and near grain boundaries can be formed during heat treatment at high temperature, but low temperatures is conducive to form the needle-like 14H-LPSO phases within α-Mg grains. During heat treatment at fixed temperature for different time, the preferential nucleation sites of the 14H-LPSO phases are located in grain boundaries, then the14H-LPSO phases grow into the α-Mg matrix in the form of needle-like, the needle-like 14H-LPSO phases gradually decrease its length after growing a certain stage, at last the needle-like 14H-LPSO phases disappear completely. The decomposition of the block-like 14H-LPSO phases is found during furnace cooling after homogenization. After decomposition of the block-like 14H-LPSO phases, the rapid diffusion of Zn atoms into α-Mg matrix leads to form the needle-like 14H-LPSO phases within α-Mg matrix, but the retention of RE atoms in grain boundaries results in forming the Mg-RE particles. After extrusion and subsequent ageing, it is found that the alloy with the needle-like 14H-LPSO phases exhibit superior elongation than the alloy without the needle-like 14H-LPSO phase. The precipitates of peak-aged alloys are studied by TEM. The <112−0>α demonstrates that the stacking faults can be observed, the serious lattice distortion appears near the stacking fault. The [0001] zone axis shows that the β′ and a new rod phase are found, and the enrichment of RE atoms are detected in the two phase by HADDF-STEM. It seems to be that the rod phase can be subdivided into a plurality of mutually parallel structure unit.

Direct observation of the 12R transition structure during the C15→C14 phase transformation in Zr(Fe, Cr) 2 Laves structured nanoparticles in Zircaloy-4

Unexpected { 01 1 ̄ 1 } pyramidal stacking faults in Zr(Fe, Cr)2 secondary phase particle induced by the C15→C14 Laves phase transformation in Zircaloy-4

Structurally modulated Zr(Fe,Cr)2 secondary phase particles in Zircaloy-4 alloy subjected to cyclic deformation at room temperature

The formation mechanism of stacking faults in ZrFe2 Laves phase in Zircaloy-4 alloy

Discovery of a bulk C36-type MgZn2 structure step by step transformed from the C14 prototype laves phase structure

Phase transition induced by synchroshear in Al-Zn-Mg-Cu alloy

Formation mechanism of composite secondary phase particles in a solution-treated Si-modified Zircaloy-4

Fracture behaviour of Zr(Fe,Cr) 2 Laves phase precipitates in Zircaloy-4 subjected to β forging

Diffusion controlled early-stage L12-D023 transitions within Al3Zr

FCC-Zr phase transformation-induced defect substructure in Zr2Si precipitates equilibrated in Si-modified Zircaloy-4

Microstructure Evolution and Failure Mechanism of Cr-coated Zry-4 in Air and Steam at 1200 °C

Transmission Electron Microscopy Observations of Structural Modulation in the Phase Transition from Α-Zr to Ω-Zr Induced by Shear Strain

Modelling amorphization and dissolution of Zr(Fe,Cr) 2 secondary phase precipitates in Zircaloys

A quantitative microscopic view on the gas‐phase‐dependent phase transformation from tetragonal to monoclinic ZrO2

Amorphous-to-Cu51Zr14phase Transformation in Cu60Ti20Zr20alloy

The Effect of Morphology of the Long-Period Stacking Ordered Phase on Mechanical Properties of the Mg-7Gd-3Y-1Nd-1Zn-0.5Zr (wt.%) Alloy

Electric Field Induced Phase Transition and Domain Structure Evolution in (pb, La)(Zr, Sn, Ti)O3 Single Crystal

Structural analysis of η 14 phase and its forming mechanism in Al-Zn-Mg-Cu alloy

Direct observation of Face-centered cubic zirconium phase growth-induced stacking faults in Zr3Ge secondary phase nanoparticle

Thickness Dependence of the Crystallization and Phase Transition in ZrO 2 Thin Films

In Situ Observation of the Atomic-scale High-temperature Phase Transition Enhancement Mechanism at the ODS-W Interface