Abstract:We studied the effects of temperature (180–260 °C) and catalytic methods (ultrafine grinding and phosphoric acid treatment) on the microwave-assisted hydrothermal carbonization of crop residues by taking rice straw, corn stover and rape stalk as the research materials. The physicochemical and structural properties of hydrochars and liquid products generated under different conditions were characterized. The results showed that with increasing temperature, the hydrochar yield of crop residues decreased from 62.97–83.09% to 42.73–57.38%; the liquid yield rose from 15.03–33.38% to 37.94–47.58%; and the gas yield increased from 1.88–4.92% to 4.68–10.90%. The liquid products were all acidic (pH = 2.53–4.40), and the NH4+–N and PO43–P concentrations respectively showed an upward trend and a downward trend with increasing temperature. Higher temperature led to enhanced carbonization degree, causing decreases in H/C and O/C atomic ratios but increases in higher heating value (HHV). Hydrochars prepared at 240 °C had the most intensified oxygenated functional groups, the largest specific surface area (5.5652–15.5058 m2/g), total pore volume (0.0403–0.1116 cm3/g) and mesopore volume (0.0395–0.1101 cm3/g), and the most carbon microspheres. However, temperature had a rather limited effect on the micropore volume of hydrochars derived from the three types of crop residues. Both ultrafine grinding and phosphoric acid catalysis could enhance hydrochar properties, with the latter being the more low-cost and efficient method. Hydrochars from ultrafine grinding crop residues had the highest peak strength of oxygenated functional groups, while those from phosphoric acid catalysis had higher fixed carbon (23.58–35.91%), C (45.03–65.50%) and HHV (17.45–27.18 MJ/kg), and lower ash content (4.21–15.67%), as well as the largest specific surface area (6.9140–15.5058 m2/g), total pore volume (0.0638–0.1116 cm3/g), micropore volume (0.0007–0.0015 cm3/g) and mesopore volume (0.0631–0.1101 cm3/g). Besides, crop residue type was also found to be an inherent factor determining hydrochar property.

Comparative study on fuel characteristics and pyrolysis kinetics of corn residue-based hydrochar produced via microwave hydrothermal carbonization

The Effect of Carbonization Conditions on Characteristics of Corn-Stalk and Rice-Straw Derived Biochar

Physicochemical, Pyrolytic, and Combustion Characteristics of Hydrochar Obtained by Hydrothermal Carbonization of Biomass

Hydrothermal Carbonization of Agricultural Biomass: Characterization of Hydrochar for Energy Production

Effects of temperature and catalytic methods on the physicochemical properties of microwave-assisted hydrothermal products of crop residues

Comparison of corn straw biochars from electrical pyrolysis and microwave pyrolysis

Porous biochar production from pyrolysis of corn straw in a microwave heated reactor

Effects of variable amounts of volatiles in corncob on microwave co-pyrolysis of low-rank coal and corncob

CO2 Gasification of Bio-Char Derived from Conventional and Microwave Pyrolysis

Characterization of Dairy Manure Hydrochar and Aqueous Phase Products Generated by Hydrothermal Carbonization at Different Temperatures

Comparing Physicochemical Properties and Sorption Behaviors of Pyrolysis-Derived and Microwave-Mediated Biochar

CO 2 gasification of biochar derived from conventional and 1 microwave pyrolysis 2

Study on the pyrolysis properties of corn straw by TG–FTIR and TG–GC/MS

Study of the Combustion , Pyrolysis Characteristics and Synergistic Effect of Co-hydrocharsation Products of Oil Shale and Rice HuskStudy of the Combustion , Pyrolysis Characteristics and Synergistic Effect of Co-hydrocharsation Products of Oil Shale and Rice Husk

Comparative analysis of conventional and microwave pyrolysis of raw materials with different degree of metamorphism

Microwave Hydrothermal Carbonization of Rice Straw: Optimization of Process Parameters and Upgrading of Chemical, Fuel, Structural and Thermal Properties

Investigation of the Effects of Co‐hydrothermal Carbonization on the Physicochemical Characteristics and Combustion Behavior of Straw Hydrochars

Co-pyrolysis of corn stalk and high-density polyethylene with emphasis on the fibrous tissue difference on thermal behavior and kinetics

Effect of Torrefaction on the Physiochemical Characteristics and Pyrolysis of the Corn Stalk

Physicochemical characteristics and pyrolysis performance of corn stalk torrefied in aqueous ammonia by microwave heating

Influence of interaction between biomass inorganic components and volatiles on corncob pyrolysis and char structure