[Analytic calculation of total urea mass in a single-pass dialysate during hemodialysis].

E. De Paoli Vitali,F. Malacarne,G. Morelli,Z. Steitieh,A. Farinelli

Abstract:

What problem does this paper attempt to address?

Extraction of collagenolytic proteases from Aspergillus heteromorphus URM 0269 in an aqueous two-phase system for application in collagen hydrolysis

Beatriz de Aquino Marques da Costa,Ana Cláudia Vaz de Araújo,Lígia Maria Gonçalves Fernandes,Ana Lúcia Figueiredo Porto,Vagne de Melo Oliveira,Tatiana Souza Porto

DOI: https://doi.org/10.1080/10826068.2023.2263870

2023-10-11

Preparative Biochemistry & Biotechnology

Abstract:Collagenolytic proteases produced by Aspergillus heteromorphus URM0269 were extracted using a PEG/sulfate aqueous two-phase system (ATPS). A 2 3 factorial design was performed to analyze the independent variables: PEG molar mass (M PEG ), PEG concentration (C PEG ), and sulfate concentration (C sulf ). The extracted proteases were also evaluated for their optimum pH and stability at different pH levels (4.0 − 11.0) after 20 h of incubation. Collagen was extracted from mutton snapper ( Lutjanus analis) skin using acetic acid (0.5 mol L −1 ). The enzyme was preferentially partitioned to the PEG-rich phase (K > 1), whose highest purification factor and recovery (PF = 6.256 and Y = 404.432%) were obtained under specific conditions: M PEG 8000 g.mol −1 , C PEG 30%, C sulf 10%. The ATPS extraction provided an enzymatic activity range of pH 7.0 − 11.0, exhibiting greater stability compared to the crude extract. Approximately 80% of protease activity was maintained after 20 hours of incubation at all analyzed pH levels, except pH 11.0. Collagen extraction from L. analis skin yielded 8.056%, and both crude extract samples and ATPS-derived samples successfully hydrolyzed the extracted collagen, reaching peak hydrolysis after 36 hours of treatment. These findings demonstrate the feasibility of extracting highly purified and active proteases capable of hydrolyzing L. analis collagen.

biotechnology & applied microbiology,biochemical research methods,biochemistry & molecular biology
PSX-B-12 Сreation of a pichia pastoris strain: A producer of recombinant peptidase M9 from Aeromonas salmonicida

Mikhail Minaev,Alexey Nagel,Zhanna Andreeva-Kovalevskaya,Marina Zakharova,Daniil Khvostov

DOI: https://doi.org/10.1093/jas/skab235.603

2021-10-08

Journal of Animal Science

Abstract:Abstract Proteases are produced by a wide variety of microorganisms and have a wide range of applications. Peptidase M9 from Aeromonas salmonicida is a 915 amino acid residue protein. Earlier, we cloned the 864 bp C end of the gene. (col2 gene) encoding the actual peptidase domain of 238 aa in the vector plasmid pPic9K. It was demonstrated that the recombinant Pichia pastoris strain, created on the basis of this plasmid, has a specific enzymatic activity against collagen. The aim of this work was to further optimize the expression of the col2 gene of the M9 peptidase domain from Aeromonas salmonicida in Pichia pastoris, isolation, purification, and characterization of the protein.First, the col2 gene was optimized based on the use of P. pastoris codons. Secondly, a study of collagenase activity with 4 different signaling sequences was carried out. It was shown that the strain for which the collagenase gene had the P. pastoris alpha peptide as a signal sequence was shown to have the maximum activity. One of the approaches leading to an increase in the yield of the target protein is the cloning of the gene encoding the chaperone proteins. We have created strains containing, in addition to the collagenase gene, also the pdi and hac chaperone genes. It was shown that the collagenase activity in the strain containing the pdi chaperone gene was 2–3 times higher than in the strain containing only the col2 gene. So, the Pichia pastoris strain was created - the producer of the recombinant peptidase M9 from Aeromonas salmonicida, the target protein was isolated and characterized.Research conducted as part of the state assignment of Gorbatov Federal Research Center for Food Systems of Russian Academy of Sciences 0437-2019-0001.

agriculture, dairy & animal science
Extracellular collagenase isolated from Streptomyces antibioticus UFPEDA 3421: purification and biochemical characterization

Elizianne Pereira Costa,Romero Marcos Pedrosa Brandão-Costa,Wendell Wagner Campos Albuquerque,Thiago Pajeú Nascimento,Amanda Emmanuelle Sales Conniff,Kethylen Barbara Barbosa Cardoso,Anna Gabrielly Duarte Neves,Juanize Matias da Silva Batista,Ana Lúcia Figueiredo Porto

DOI: https://doi.org/10.1080/10826068.2023.2225090

Abstract:Collagenases are proteases able to degrade native and denatured collagen, with broad applications such as leather, food, and pharmaceutical industries. The aim of this research was to purify and characterize a collagenase from Streptomyces antibioticus. In the present work, the coffee ground substrate provided conditions to obtaining high collagenase activity (377.5 U/mL) using anion-exchange DEAE-Sephadex G50 chromatographic protocol. SDS-PAGE revealed the metallo-collagenase with a single band of 41.28 kDa and was able to hydrolyzed type I and type V collagen producing bioactive peptides that delayed the coagulation time. The enzyme activity showed stability across a range of pH (6.0-11) and temperature (30-55 °C) with optima at pH 7.0 and 60 °C, respectively. Activators include Mg+2, Ca+2, Na+, K+, while full inhibition was given by other tested metalloproteinase inhibitors. Kinetic parameters (Km of 27.14 mg/mol, Vmax of 714.29 mg/mol/min, Kcat of 79.9 s-1 and Kcat/Km of 2.95 mL/mg/s) and thermodynamic parameters (Ea of 65.224 kJ/mol, ΔH of 62.75 kJ/mol, ΔS of 1.96 J/mol, ΔG of 62.16 kJ/mol, ΔGE-S of 8.18 kJ/mol and ΔGE-T of -2.64 kJ/mol) were also defined. Coffee grounds showed to be an interesting source to obtaining a collagenase able to produce bioactive peptides with anticoagulant activity.
Purification, characterization and application of collagenolytic protease from Bacillus subtilis strain MPK

Madhuri Vijay Bhuimbar,Chidambar Balbhim Jalkute,Prashant Kishor Bhagwat,Padma Babulal Dandge

DOI: https://doi.org/10.1016/j.jbiosc.2024.03.003

Abstract:A new extracellular protease from Bacillus subtilis strain MPK with collagenolytic activity was isolated and purified. Fish skin which otherwise would be treated as waste is used as substrate for the production of protease. Using various techniques such as ammonium sulphate precipitation and ion exchange chromatography, protease was purified and characterized subsequently. Protease of approximately 61 kDa molecular weight was purified by 135.7-fold with 18.42% enzyme recovery. The protease showed effective properties like pH and temperature stability over a broad range with optimum pH 7.5 and temperature 60 °C. Km and Vmax were found to be 1.92 mg ml-1 and 1.02 × 10-4 mol L-1 min-1, respectively. The protease exhibited stability in various ions, surfactants, inhibitors and organic solvents. Subsequently, the protease was successfully utilized for collagen hydrolysis to generate collagen peptides; thus, the produced protease would be a potential candidate for multifaceted applications in food and pharmaceutical industries due to its significant characteristics and collagenolytic properties.
Production and Purification of Human Fibroblast Collagenase (MMP-1) Expressed in the Methylotrophic YeastPichia pastoris

Stuart A. Rosenfeld,O.Harold Ross,Milton C. Hillman,Jeanne I. Corman,Randine L. Dowling

DOI: https://doi.org/10.1006/prep.1996.0063

IF: 2.025

1996-06-01

Protein Expression and Purification

Abstract:The cDNA that encodes the proenzyme form of human fibroblast collagenase (proMMP-1) was expressed in the methylotrophic yeast Pichia pastoris. The proMMP-1 encoding DNA was fused to the Saccharomyces cerevisiae pre-pro alpha-mating factor secretion signal in the P. pastoris pPIC9 expression plasmid, transformed into strain GS115 (His-), and His+ Muts (slow methanol utilization) transformants were selected. Full-length proenzyme and processed forms of the protein could be detected in yeast culture supernatants following shake flask and 10-liter fermentations. The protein was purified to greater than 95% homogeneity. The recombinant proMMP-1 was comparable to the native fibroblast material based on (i) migration of the full-length molecule as a 52-kDa protein on reducing SDS-PAGE, (ii) correct N-terminal amino acid sequence, (iii) activation of the full-length molecule by 4-amino-phenylmercuric acetate to yield processed protein species, (iv) degradation of gelatin as monitored by zymogram gels, and (v) enzymatic activity. These data suggest that the P. pastoris expression system offers a convenient and efficient means to produce and purify MMP-1.

biochemistry & molecular biology,biochemical research methods,biotechnology & applied microbiology
Pichia pastoris production of a prolyl 4-hydroxylase derived from Chondrosia reniformis sponge: A new biotechnological tool for the recombinant production of marine collagen

Marina Pozzolini,Sonia Scarfì,Francesca Mussino,Annalisa Salis,Gianluca Damonte,Umberto Benatti,Marco Giovine

DOI: https://doi.org/10.1016/j.jbiotec.2015.05.007

2015-08-20

Abstract:Prolyl 4-hydroxylase (P4H) is a α2β2 tetramer catalyzing the post-translational hydroxylation of prolines in collagen. Its recombinant production is mainly pursued to realize biotechnological tools able to generate animal contaminant-free hydroxylated collagen. One promising candidate for biomedical applications is the collagen extracted from the marine sponge Chondrosia reniformis, because of its biocompatibility and because is devoid of the health risks associated with bovine and porcine collagens. Here we report on the production and selection, by enzymatic and biomolecular analyses, of a triple transformed Pichia pastoris strain expressing a stable P4H tetramer derived from C. reniformis sponge and a hydroxylated non fibrillar procollagen polypeptide from the same animal. The percentage of recombinant procollagen hydroxylated prolines inside the transformed yeast was of 36.3% analyzed by mass spectrometry indicating that the recombinant enzyme is active on its natural substrate inside the yeast cell host. Furthermore, the recombinant sponge P4H has the ability to hydroxylate its natural substrate in both X and Y positions in the Xaa-Yaa-Gly collagenous triplets. In conclusion this Pichia system seems ideal for high-level production of hydroxylated sponge- or marine-derived collagen polypeptides as well as of conotoxins or other marine proteins of high pharmacological interest needing this particular post-translational modification.
[Enzymatic activity of recombinant metallopeptidase for further using in meat industry]

A A Makhova,M Yu Minaev,A V Kulikovsky,N L Vostrikova

DOI: https://doi.org/10.24411/0042-8833-2019-10047

Abstract:Enzymatic modification of meat with a high content of connective tissue is an effective mean, allowing to improve its properties and expand its use. Microbial enzymes have been extensively investigated as meat tenderizers. Compliance with safety requirements in terms of forecasting the development of various risks is essential for the use of these enzymes in food industry. The method of producing recombinant protease as a potential candidate for applications on meat tenderization was described in the article. The aim of this study was the production of recombinant Pichia pastoris with M9 peptidase gene from Aeromonas salmonicida. Material and methods. Objects: peptidase gene M9 (GenBank: CP000644.1 ASA_3723) Aeromonas salmonicida (strain of laboratory collection, isolated from the surface of raw meat), the vector plasmid pPic9K, competent E. coli DH5α cells, competent Pichia pastoris GS115 cells, culture fluid (QOL) from recombinant Pichia pastoris clones, beef shank samples. To obtain a recombinant strain, genetic engineering methods, the PCR method, and the bacteriological method were used. Polyacrylamide gel electrophoresis was used to separate and analyze the components of the supernatant. Enzyme activity was evaluated by HPLC-MS/MS using synthesized peptides. The impact of the supernatant from recombinant clones on the connective tissue of raw meat was assessed by histological method. Results and discussion. A metalloprotease M9 gene was cloned from the Aeromonas salmonicida (2748 bp) and expressed in Pichia pastoris. The molecular mass of the recombinant protein was estimated to be 120 kDa by SDS-PAGE. Histological analyses of the control and enzyme treated beef samples showed degradation intramuscular connective tissue, suggesting its effectiveness on meat tenderization. Conclusion. The recombinant strain Pichia pastoris, which produces the recombinant M9 peptide of Aeromonas salmonicida, has a specific enzymatic activity against collagen, the main component of the connective tissue of meat. The obtained recombinant peptidase M9 can be used as an enzyme softener of raw meat with a high content of connective tissue.
Aspergillus Proteolytic Enzymes Hydrolyzing Fibrillar Proteins for Biomedicine and Biotechnological Processes

Osmolovskiy, A. A.

DOI: https://doi.org/10.3103/S0096392522030099

2022-11-08

Moscow University Biological Sciences Bulletin

Abstract:Fibrillar proteins play a significant role in the functioning of living organisms, and much attention has been paid to them recently as targets in the therapy and diagnosis of various diseases, substrates for the biopolymers production, and industrially important proteins that are key agents in textile and food manufacture. To implement the development of these directions, fibrillar proteins' hydrolysis and processing methods are needed, the most promising of which is the use of proteolytic enzymes. A total of 11 enzyme preparations obtained by cultivation of micromycetes that belong to the genus Aspergillus and contain from 1 to 10 proteins were studied for the ability to hydrolyze fibrillar proteins: collagen, keratin, fibrin, and elastin. The proteolytic enzymes of A. alliaceus 7dN1, A. clavatus A16, and A. ustus 1 showed an activity comparable to or higher than that of the commercial preparation terrilytin used in wound therapy. The A. fumigatus D1 enzyme preparation also showed a high level of fibrinolytic activity.
Gene Analysis, Cloning, and Heterologous Expression of Protease from a Micromycete Aspergillus ochraceus Capable of Activating Protein C of Blood Plasma

Sergei K. Komarevtsev,Peter V. Evseev,Mikhail M. Shneider,Elizaveta A. Popova,Alexey E. Tupikin,Vasiliy N. Stepanenko,Marsel R. Kabilov,Sergei V. Shabunin,Alexander A. Osmolovskiy,Konstantin A. Miroshnikov

DOI: https://doi.org/10.3390/microorganisms9091936

IF: 4.5

2021-09-11

Microorganisms

Abstract:Micromycetes are known to secrete numerous enzymes of biotechnological and medical potential. Fibrinolytic protease-activator of protein C (PAPC) of blood plasma from micromycete Aspergillus ochraceus VKM-F4104D was obtained in recombinant form utilising the bacterial expression system. This enzyme, which belongs to the proteinase-K-like proteases, is similar to the proteases encoded in the genomes of Aspergillus fumigatus ATCC MYA-4609, A. oryzae ATCC 42149 and A. flavus 28. Mature PAPC-4104 is 282 amino acids long, preceded by the 101-amino acid propeptide necessary for proper folding and maturation. The recombinant protease was identical to the native enzyme from micromycete in terms of its biological properties, including an ability to hydrolyse substrates of activated protein C (pGlu-Pro-Arg-pNA) and factor Xa (Z-D-Arg-Gly-Arg-pNA) in conjugant reactions with human blood plasma. Therefore, recombinant PAPC-4104 can potentially be used in medicine, veterinary science, diagnostics, and other applications.

microbiology
[ON HIGHLY PURIFIED PVA AS AN INSERTED MEMBRANE (BY THE AKIYAMA METHOD). (1. EXPERIMENTS ON INSERTION INTO THE JOINT)].

T. Aoki,S. Takasago,T. Matsumoto,Y. Matsuura,S. Inoue,H. Kudo

1964-09-01

Abstract:
Produção de protease colagenolítica por Bacillus stearothermophillus de solo amazônico

Lorena Azevedo Lima,Raimundo Felipe Cruz Filho,Januário Gama dos Santos,Wilson Castro Silva

DOI: https://doi.org/10.1590/1809-4392201305074

2014-12-01

Acta Amazonica

Abstract:As proteases colagenolíticas são enzimas capazes de hidrolisar as ligações peptídicas de vários tipos de colágeno e têm grande importância na medicina e em aplicações terapêuticas. O objetivo desta pesquisa foi avaliar a produção de proteases colagenolíticas por Bacillus stearothermophilus. Os tratamentos foram realizados por meio de um planejamento fatorial completo 23, a fim de avaliar a significância dos efeitos e interações das variáveis - pH inicial, concentração de substrato e temperatura - sobre a produção de protease colagenolítica. O ponto central foi executado em quadruplicata para fornecer uma estimativa dos erros experimentais. Ensaios enzimáticos com colágeno e azocaseína como substratos foram realizados para determinação das atividades colagenolítica e proteolítica respectivamente. A maior atividade enzimática colagenolítica foi 79,38 U mL-1, correspondendo a atividade específica de 136,86 U mg-1, em condições iniciais de fermentação, na concentração de substrato a 1% (p/v), pH 7,2 e 25 °C. A atividade proteolítica da enzima foi mais ativa em pH 9,0 e 50 °C e foi estável nas faixas de pH (6,0 - 9,0) e temperatura (45 °C - 50 °C). Bacillus stearothermophilus apresenta viabilidade para a produção de proteases colagenolíticas e a obtenção dessas enzimas tem grande importância para aplicações biotecnológicas.

ecology,plant sciences,zoology
Biosynthesis of a Functional Fragment of Human Collagen II in Pichia pastoris.

Jingwen Zhou,Shuyao Yu,Kangjie Xu,Kun Wang,Xinyi Zhao,Ruoxi Sun,Xinglong Wang,Yijian Rao

DOI: https://doi.org/10.1021/acssynbio.4c00345

IF: 5.249

2024-08-02

ACS Synthetic Biology

Abstract:Collagen II (COL2) is the major component of cartilage tissue and is widely applied in pharmaceuticals, food, and cosmetics. In this study, COL fragments were extracted from human COL2 for secretory expression in Pichia pastoris. Three variants were successfully secreted by shake flask cultivation with a yield of 73.3-100.7 mg/L. The three COL2 variants were shown to self-assemble into triple-helix at 4 °C and capable of forming higher order assembly of nanofiber and hydrogel. The bioactivities of the COL2 variants were validated, showing that sample 205 exhibited the best performance for inducing fibroblast differentiation and cell migration. Meanwhile, sample 205 and 209 exhibited higher capacity for inducing in vitro blood clotting than commercial mouse COL1. To overexpress sample 205, the expression cassettes were constructed with different promoters and signal peptides, and the fermentation condition was optimized, obtaining a yield of 172 mg/L for sample 205. Fed-batch fermentation was carried out using a 5 L bioreactor, and the secretory protease Pep4 was knocked out to avoid sample degradation, finally obtaining a yield of 3.04 g/L. Here, a bioactive COL2 fragment was successfully identified and can be overexpressed in P. pastoris; the variant may become a potential biomaterial for skin care.

Biology,Medicine,Materials Science
Web 2.0 driven Open Innovation Networks

Michael Reinhardt,M. Frieß,Georg Groh,M. Wiener,M. Amberg

Abstract:
High-expression and characterization of a novel serine protease from Ornithinibacillus caprae L9T with eco-friendly applications

Xiaoguang Li,Qian Zhang,Zhe Xu,Guangyang Jiang,Longzhan Gan,Yongqiang Tian,Bi Shi

DOI: https://doi.org/10.1007/s11356-021-17495-2

IF: 5.8

2022-01-21

Environmental Science and Pollution Research

Abstract:In the current work, a novel thermophilic serine protease gene (P3862) from Ornithinibacillus caprae L9T was functionally expressed in Bacillus subtilis SCK6. The monomeric enzyme of about 29 kDa was purified to homogeneity with 43.91% of recovery and 2.81-folds of purification. Characterization of the purified protease revealed the optimum activity at pH 7 and 65 °C. The protease exhibited excellent activity and stability in the presence of Na+, Mg2+, Ca2+, ethanediol, n-hexane, Tween-20, Tween-80 and Triton X-100. P3862 displayed favorable caseinolytic activity, moderate keratinolytic activity but no collagenolytic activity. Besides, the homology model of P3862 possessed a globular configuration and characteristic of α/β hydrolase fold, and displayed stable interactions with casein, glycoprotein and keratin rather than collagen. Moreover, the crude enzyme could completely dehair goatskin within 6 h, resulting in decrease in BOD5, COD and TSS loads by 72.86, 74.07, and 73.79%, respectively, as compared with Na2S treatment. Biocatalytic applications revealed that it could effectively remove egg-stains from fabrics at 37 °C for 30 min with low supplementation (300 U/mL), and was able to degrade the feathers of duck and chicken. Overall, these outstanding properties make P3862 valuable in the development of environmentally friendly biotechnologies .

environmental sciences
Production and Functional Analysis of Collagen Hexapeptide Repeat Sequences in Pichia pastoris

Xiaoyan Guo,Pan Wang,Weigang Yuwen,Chenhui Zhu,Rongzhan Fu,Pei Ma,Zhiguang Duan,Daidi Fan

DOI: https://doi.org/10.1021/acs.jafc.4c00582

2024-05-27

Abstract:In the development of biomaterials with specific structural domains associated with various cellular activities, the limited integrin specificity of commonly used adhesion sequences, such as the RGD tripeptide, has resulted in an inability to precisely control cellular responses. To overcome this limitation, we conducted multiple replications of the integrin α2β1-specific ligand, the collagen hexapeptide Gly-Phe-Pro-Gly-Glu-Arg (GFPGER) in Pichia pastoris. This enabled the development of recombinant collagen with high biological activity, which was subsequently expressed, isolated, and purified for structural and functional analysis. The proteins carrying the multiple replications GFPGER sequence demonstrated significant bioactivity in cells, leading to enhanced cell adhesion, osteoblast differentiation, and mineralization when compared to control groups. Importantly, these effects were mediated by integrin α2β1. The new collagen constructed in this study is expected to be a biomaterial for regulating specific cell functions and fates.
High-efficiency secretory expression and characterization of the recombinant type III human-like collagen in Pichia pastoris

Zhi-Xiang Xiang,Jin-Song Gong,Jin-Hao Shi,Chun-Fang Liu,Heng Li,Chang Su,Min Jiang,Zheng-Hong Xu,Jin-Song Shi

DOI: https://doi.org/10.1186/s40643-022-00605-4

2022-11-05

Bioresources and Bioprocessing

Abstract:Collagen, the highest content protein in the body, has irreplaceable biological functions, and it is widespread concerned in food, beauty, and medicine with great market demand. The gene encoding the recombinant type III human-like collagen α1 chain fragment was integrated into P. pastoris genome after partial amino acids were substituted. Combined with promoter engineering and high-density fermentation technology, soluble secretory expression with the highest yield of 1.05 g L −1 was achieved using two-stage feeding method, and the purity could reach 96% after affinity purification. The determination of N / C -terminal protein sequence were consistent with the theoretical expectation and showed the characteristics of Gly-X-Y repeated short peptide sequence. In amino acid analysis, glycine shared 27.02% and proline 23.92%, which were in accordance with the characteristics of collagen. Ultraviolet spectrum combined with Fourier transform infrared spectroscopy as well as mass spectrometry demonstrated that the target product conformed to the characteristics of collagen spectrums and existed as homologous dimer and trimer in the broth. This work provided a sustainable and economically viable source of the recombinant type III human-like collagen.

biotechnology & applied microbiology
Temperature-Controlled Expression of a Recombinant Human-like Collagen I Peptide in Escherichia coli

Wenjie Xie,Qiqi Wu,Zhanpeng Kuang,Jianhang Cong,Qirong Zhang,Yadong Huang,Zhijian Su,Qi Xiang

DOI: https://doi.org/10.3390/bioengineering10080926

2023-08-04

Abstract:Collagen is the functional protein of the skin, tendons, ligaments, cartilage, bone, and connective tissue. Due to its extraordinary properties, collagen has a wide range of applications in biomedicine, tissue engineering, food, and cosmetics. In this study, we designed a functional fragment of human type I collagen (rhLCOL-I) and expressed it in Escherichia coli (E. coli) BL21(DE3) PlysS containing a thermal-induced plasmid, pBV-rhLCOL-I. The results indicated that the optimal expression level of the rhLCOL-I reached 36.3% of the total protein at 42 °C, and expressed in soluble form. In a 7 L fermentation, the yield of purified rhLCOL-I was 1.88 g/L. Interestingly, the plasmid, pBV220-rhLCOL-I, was excellently stable during the fermentation process, even in the absence of antibiotics. Functional analyses indicated that rhLCOL-I had the capacity to promote skin cell migration and adhesion in vitro and in vivo. Taken together, we developed a high-level and low-cost approach to produce collagen fragments suitable for medical applications in E. coli.
High-level production of human collagen prolyl 4-hydroxylase in Escherichia coli

Antje Neubauer,Peter Neubauer,Johanna Myllyharju

DOI: https://doi.org/10.1016/j.matbio.2004.11.004

Abstract:The collagen prolyl 4-hydroxylases (C-P4Hs), enzymes residing within the lumen of the endoplasmic reticulum, play a central role in the synthesis of all collagens. The vertebrate enzymes are alpha(2)beta(2) tetramers in which the two catalytic sites are located in the alpha subunits, and protein disulfide isomerase serves as the beta subunit. All attempts to assemble an active C-P4H tetramer from its subunits in in vitro cell-free systems have been unsuccessful, but assembly of a recombinant enzyme has been reported in several cell types by coexpression of the two types of subunit. An active type I C-P4H tetramer was obtained here by periplasmic expression in Escherichia coli strains BL21 and RB791. Further optimization for production by stepwise regulated coexpression of its subunits in the cytoplasm of a thioredoxin reductase and glutathione reductase mutant E. coli strain resulted in large amounts of human type I C-P4H tetramer. The specific activity of the C-P4H tetramer purified from the cytoplasmic expression was within the range of values reported for human type I C-P4H isolated as a nonrecombinant enzyme or produced in the endoplasmic reticulum of insect cells, but the expression level, about 25 mg/l in a fermenter, is about 5-10 times that obtained in insect cells. The enzyme expressed in E. coli differed from those present in vivo and those produced in other hosts in that it lacked the N glycosylation of its alpha subunits, which may be advantageous in crystallization experiments.
Production of bacterial protease via solid-state cultivation with agro-industrial by-products and eco-friendly perspectives of enzyme application

Carolina Becker da Silva,Gabriela Poll Moraes,Rubia Godoy Hoffmann,Tainara Lenz Goettems,Amanda Mendonça Azambuja,Daniel Joner Daroit

DOI: https://doi.org/10.1007/s10098-024-02943-7

IF: 4.3

2024-07-14

Clean Technologies and Environmental Policy

Abstract:Microbial proteases are relevant biotechnological tools, contributing to industrial development from a greener standpoint. Its cost-effective production is an important topic, and solid-state cultivation (SSF) represents a simple and economical approach to this end. Hence, SSF parameters were investigated to increase protease production by Bacillus sp. CL18, and the potential applications of the crude enzyme were evaluated. Among six agro-industrial by-products screened as SSF substrates (5 g), higher protease production occurred with corn silage discards (spoiled silage). Yields were increased at 80% moisture, using a salts-based moistening agent, and 1 mL inoculum. Replacement of silage discards by soybean meal (80:20%) augmented protease production, reaching maximal yields after 4 days at 30 °C. The crude protease exhibited milk-clotting activity (optimal at 55 °C), and effectively removed the gelatin-silver emulsion layer from radiographic/photographic films (15 min, 50 °C). The enzyme was compatible with a laundry detergent, removing blood stains from cloths and enhancing detergent performance. The protease hydrolyzed porcine livers and spleens, and protein hydrolysates showed increased radical-scavenging and Fe 2+ -chelating activities. Therefore, a versatile protease was obtained through SSF with an unexplored residual biomass. The crude protease is particularly promising for silver reclamation and in the expanding field of bioactive hydrolysates produced from abundant and undervalued slaughterhouse by-products.

environmental sciences,engineering, environmental,green & sustainable science & technology
Bacterial and Fungal Proteolytic Enzymes: Production, Catalysis and Potential Applications

Ronivaldo Rodrigues da Silva

DOI: https://doi.org/10.1007/s12010-017-2427-2

2017-02-03

Applied Biochemistry and Biotechnology

Abstract:Submerged and solid-state bioprocesses have been extensively explored worldwide and employed in a number of important studies dealing with microbial cultivation for the production of enzymes. The development of these production technologies has facilitated the generation of new enzyme-based products with applications in pharmaceuticals, food, bioactive peptides, and basic research studies, among others. The applicability of microorganisms in biotechnology is potentiated because of their various advantages, including large-scale production, short time of cultivation, and ease of handling. Currently, several studies are being conducted to search for new microbial peptidases with peculiar biochemical properties for industrial applications. Bioprospecting, being an important prerequisite for research and biotechnological development, is based on exploring the microbial diversity for enzyme production. Limited information is available on the production of specific proteolytic enzymes from bacterial and fungal species, especially on the subgroups threonine and glutamic peptidases, and the seventh catalytic type, nonhydrolytic asparagine peptide lyase. This gap in information motivated the present study about these unique biocatalysts. In this study, the biochemical and biotechnological aspects of the seven catalytic types of proteolytic enzymes, namely aspartyl, cysteine, serine, metallo, glutamic, and threonine peptidase, and asparagine peptide lyase, are summarized, with an emphasis on new studies, production, catalysis, and application of these enzymes.

biotechnology & applied microbiology,biochemistry & molecular biology

[Analytic calculation of total urea mass in a single-pass dialysate during hemodialysis].

Extraction of collagenolytic proteases from Aspergillus heteromorphus URM 0269 in an aqueous two-phase system for application in collagen hydrolysis

PSX-B-12 Сreation of a pichia pastoris strain: A producer of recombinant peptidase M9 from Aeromonas salmonicida

Extracellular collagenase isolated from Streptomyces antibioticus UFPEDA 3421: purification and biochemical characterization

Purification, characterization and application of collagenolytic protease from Bacillus subtilis strain MPK

Production and Purification of Human Fibroblast Collagenase (MMP-1) Expressed in the Methylotrophic YeastPichia pastoris

Pichia pastoris production of a prolyl 4-hydroxylase derived from Chondrosia reniformis sponge: A new biotechnological tool for the recombinant production of marine collagen

[Enzymatic activity of recombinant metallopeptidase for further using in meat industry]

Aspergillus Proteolytic Enzymes Hydrolyzing Fibrillar Proteins for Biomedicine and Biotechnological Processes

Gene Analysis, Cloning, and Heterologous Expression of Protease from a Micromycete Aspergillus ochraceus Capable of Activating Protein C of Blood Plasma

[ON HIGHLY PURIFIED PVA AS AN INSERTED MEMBRANE (BY THE AKIYAMA METHOD). (1. EXPERIMENTS ON INSERTION INTO THE JOINT)].

Produção de protease colagenolítica por Bacillus stearothermophillus de solo amazônico

Biosynthesis of a Functional Fragment of Human Collagen II in Pichia pastoris.

Web 2.0 driven Open Innovation Networks

High-expression and characterization of a novel serine protease from Ornithinibacillus caprae L9T with eco-friendly applications

Production and Functional Analysis of Collagen Hexapeptide Repeat Sequences in Pichia pastoris

High-efficiency secretory expression and characterization of the recombinant type III human-like collagen in Pichia pastoris

Temperature-Controlled Expression of a Recombinant Human-like Collagen I Peptide in Escherichia coli

High-level production of human collagen prolyl 4-hydroxylase in Escherichia coli

Production of bacterial protease via solid-state cultivation with agro-industrial by-products and eco-friendly perspectives of enzyme application

Bacterial and Fungal Proteolytic Enzymes: Production, Catalysis and Potential Applications