Abstract:Nowadays, the zero liquid discharge of flue gas desulfurization (FGD) wastewater from coal-fired units has attracted the attention of all countries in the world. The pretreatment methods generally have the problems of high operation cost, small treatment capacity, and poor flexibility. However, the membrane method can avoid the above problems. In the current research, it has not been found that someone directly uses submerged ultrafiltration to pretreat FGD wastewater. Therefore, this paper innovatively proposed to directly use ceramic ultrafiltration membrane to treat FGD wastewater, which can ensure effluent quality and improve the flexibility of the pretreatment system. In this paper, the performance of submerged ultrafiltration membrane for the filtration of FGD wastewater from a power plant was studied to optimize the filtration performance and improve the effluent quality. The effects of operating parameters such as membrane permeate flux, aeration rate and filtration/backwashing time combination on the membrane performance were studied. The results showed that when the filtration/backwashing time combination was 15 min/30 s, with the increased in permeate flux from 55 L/(m2·h) to 100 L/(m2·h), the steady transmembrane pressure (TMP) increased from 39 kPa to 70 kPa, and the fouling rate increased significantly from 4.5 kPa/h to 7.3 kPa/h; When the aeration rate increased from 10 m3/(m2·h) to 30 m3/(m2·h), the membrane pollution was much reduced. Excessive aeration rate cannot further alleviate the membrane pollution, but also brought greater energy consumption; Increasing backwashing time can effectively inhibit the formation of gel layer on the surface of the membrane and prolong the initial stage of low-pressure operation; The rejection of suspended solids (SS) and turbidity of the equipment studied in this paper can reach more than 99% under various working conditions, which can satisfy the water quality requirements of the subsequent steps. The submerged ultrafiltration membrane was suitable for the pretreatment of FGD wastewater because it can ensure the quality of permeate under the premise of long-term operation.

Insight into the magnetic lime coagulation-membrane distillation process for desulfurization wastewater treatment: From pollutant removal feature to membrane fouling

Revealing the brick-laying process of foulants layer in membrane distillation for desulfurization wastewater treatment: Insight into the mineral scaling

Distribution and transformation of dissolved organic matters (DOMs) in membrane distillation for desulfurization wastewater in thermal power plant

Treatment of Flue Gas Desulfurization Wastewater by a Coupled Precipitation-Ultrafiltration Process

Mixed scaling deconstruction in vacuum membrane distillation for desulfurization wastewater treatment by a cascade strategy

Improved Ultrafiltration Performance Through Dielectric Barrier Discharge/sulfite Pretreatment: Effects of Water Matrices and Mechanistic Insights

Fenton pretreatment to mitigate membrane distillation fouling during treatment of landfill leachate membrane concentrate: Performance and mechanism

Treatment of coal gasification brine by membrane distillation: Effect of mixed fouling and pretreatment on process performance

Coupling Ferrate Pretreatment and In-Situ Ozonation/ceramic Membrane Filtration for Wastewater Reclamation: Water Quality and Membrane Fouling

Application of Submerged Ultrafiltration in Pretreatment of Flue Gas Desulfurization Wastewater

Treatment of Flue Gas Desulfurization Wastewater with Near-Zero Liquid Discharge by Nanofiltration-Membrane Distillation Process

Characterization and Mitigation of the Fouling of Flat-Sheet Ceramic Membranes for Direct Filtration of the Coagulated Domestic Wastewater

Purification of dredged water by magnetic coagulation: Response surface optimization and dissolved organic matter removal characteristics

Investigation of fouling mechanism in membrane distillation using in-situ optical coherence tomography with green regeneration of fouled membrane

Improving membrane distillation performance by Fe(II) activated sodium percarbonate oxidation during the treatment of shale gas produced water

Membrane Fouling of Raw Coking Wastewater in Membrane Distillation: Identification of Fouling Potential of Hydrophilic and Hydrophobic Components

Coagulation/co-catalytic membrane integrated system for fouling-resistant and efficient water purification

Fluidized-bed Fenton coupled with ceramic membrane separation for advanced treatment of flax wastewater

Membrane Fouling Characteristics and Mitigation in a Coagulation-Assisted Microfiltration Process for Municipal Wastewater Pretreatment.

Novel Approach to Landfill Wastewater Treatment Fouling Mitigation: Air Gap Membrane Distillation with Tin Sulfide-Coated PTFE Membrane

Synergistic Mechanism of Combined Ferrate and Ultrafiltration Process for Shale Gas Wastewater Treatment