Abstract:Rapid and sensitive H2 detection is important because of its low threshold for the formation of explosive mixtures in air (∼4%). Palladium's unique interactions with H2 make it particularly useful in room-temperature H2 sensing, but the formation of water by reaction with O2 at the Pd surface can interfere with sensor response. Here, we report H2 sensors using networks of high aspect ratio and ultrathin reduced graphene oxide (rGO)-coated palladium nanowires (Pd ) with a coating of zeolite imidazole framework (ZIF-8) that serves as a nanofiltration layer. We first produced Pd NWs in high yield by a hydrothermal method, then sonicated them with GO and added a reducing agent to produce Pd Thin Pd NWs promote rapid response and high sensitivity, while rGO prevents the formation of additional conductive channels due to expansion of Pd NWs upon H2 exposure, ensuring monotonic sensor response. The coating of ZIF-8 reduces the transport of molecules like oxygen and nitrogen to the Pd NWs while allowing H2 to reach them and H2O to diffuse away from them. The optimized sensors showed a response (relative change in resistance) to 1% H2 in air of up to 2%, with a response time of 5 s and a lower limit of detection of 20 ppm. Relative to previously reported Pd-based H2 sensors with fast response, the Pd @ZIF-8 nanocomposite-based device provides a low-cost, high-performance sensor solution for fuel-cell vehicles and similar applications that require both rapid and sensitive H2 detection.The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acsanm.1c01348.FTIR spectra of GO and Pd ; representative EDS spectrum of a bulk Pd nanocomposite material; EDS spectrum of an individual Pd as obtained from STEM imaging; SEM image of a Pd sensor, SEM image of a Pd @ZIF-8 sensor and corresponding elemental mapping of the sensor; XPS spectrum of Pd for (a) Ca 2P, (b) O 1s; Pd NWs (c) C 1s, (d) O 1s; hysteresis curve and the corresponding dynamic H2 sensing curve for Pd NWs; response vs H2 concentration curve of and @ZIF-8 sensors; TEM images, dynamic H2 sensing performance, and EDS spectra of 2 ; comparison of sensor response to repeated exposure to 1% H2; response, response time, and recovery time of Pd NWs, Pd , and Pd @ZIF-8 H2 sensor; the response of @ZIF-8 sensor to 100 ppm of H2, CO, CH4, and CO2; and comparison of dynamic H2 sensor performance of the Pd @ZIF-8 sensor on day 1 and on day 150 (PDF)This article has not yet been cited by other publications.

Pd nanocrystal sensitization two-dimension porous TiO2 for instantaneous and high efficient H2 detection

Sensitive H2 Gas Sensors Based on SnO2 Nanowires

Nano-Schottky Junction-Engineered Pd/SnO2 Nanotube Array for Ultrasensitive Hydrogen Sensing at Room Temperature

Enhancement of H2 Gas Sensing Using Pd Decoration on ZnO Nanoparticles

One-Step Photochemical Deposition of Pdau Alloyed Nanoparticles on Tio2 Nanowires for Ultra-Sensitive H-2 Detection

In-situ synthesis of needle-like PdO-decorated NiO thin films on Al2O3 substrates for high-performance H2 sensors

Theory-guided design of Pd/C nanocomposite for H2 sensing at room-temperature

Pd nanoparticles decorated SnO 2 ultrathin nanosheets for highly sensitive H 2 sensor: Experimental and theoretical studies

Ultralow detection limit and ultrafast response/recovery of the H2 gas sensor based on Pd-doped rGO/ZnO-SnO2 from hydrothermal synthesis

Hydrogen Sensitivity Performance of Pd Doped SnO2 Nanostructured Film Fabricated by Spray Pyrolysis

Flexible and lightweight Ti3C2Tx MXene@Pd colloidal nanoclusters paper film as novel H2 sensor

Controllable Fabrication of PdO‐PdAu Ternary Hollow Shells: Synergistic Acceleration of H 2 ‐Sensing Speed via Morphology Regulation and Electronic Structure Modulation

Reduced Graphene Oxide-Wrapped Palladium Nanowires Coated with a Layer of Zeolitic Imidazolate Framework-8 for Hydrogen Sensing

Optimizing coverage of palladium nanoparticles for a highly sensitive hydrogen gas sensor based on nanogaps via spray-deposition

Innovative Thermocatalytic H2 Sensor with Double-Sided Pd Nanocluster Films on an Ultrathin Mica Substrate

Three-Dimensional Porous Carbon/Nitrogen Framework-Decorated Palladium Nanoparticles for Stable and Wide-Concentration-Range Hydrogen Sensing

Highly Sensitive Detection of Hydrogen Gas Using Nanoporous Composites of Halloysite Nanotubes and Palladium

Room Temperature Hydrogen Sensitivities of a New Type Hydrogen Sensor with Pd Nanoclusters/tio2 Nanotubes Composite Structure

Boosting room temperature response of Pd-based hydrogen sensor by constructing in situ nanoparticles

Low detection based on Pd Pt /In2O3 nanospheres for rapid hydrogen detection

Dual Mechanisms of Pd-Doped In 2 O 3 /CeO 2 Nanofibers for Hydrogen Gas Sensing