Abstract:In the present work, the gasification performances of two pairs of raw and torrefied biomasses, including raw forest residue and torrefied forest residue, and raw spruce and torrefied spruce in a high-temperature entrained-flow reactor, are numerically examined and compared to each other using a Eulerian-Lagrangian CFD model developed based on OpenFOAM. Moreover, the sensitivities of three important operating parameters (excess air ratio, steam/carbon molar ratio, and biomass particle diameter), which vary in the range of practical significance, are also tested. The calculated results are analyzed both qualitatively and quantitatively by five indicators: isothermal profiles, char consumption rate, gas compositions, species yield, and carbon conversion along the reactor length. The obtained results show that torrefied biomass can increase the maximum temperature in the reactor as compared to its raw parent fuel. During gasification, CO, H-2, and CO2 are the major species in the product gas and CH4 accounts for only a very small fraction of the syngas at such a high operating temperature of 1400 degrees C. As expected, the higher the excess air ratio, the lower the H-2 yield and higher CO2 production and carbon conversion; a rise in the steam/carbon molar ratio promotes the H-2 yield but reduces the CO production; and both the H-2 and CO yields and carbon conversion decrease with increasing particle diameter. In addition, three reaction zones can be recognized from the carbon conversion along the reactor length, and such information is useful for optimal reactor design. In all cases, torrefaction consistently reduces both the H-2 production and carbon conversion as compared to its raw biomass under the same operating conditions, which suggests that torrefied biomass requires a bigger length entrained-flow gasifier or longer particle residence time to achieve the same level of conversion as that for its raw biomass.

Carbon dioxide-steam reforming gasification of carbonized biomass pellet for high syngas yield and TAR reduction through CFD modeling

Influence of Torrefaction on Biomass Gasification Performance in A High-Temperature Entrained-Flow Reactor

Effects of Steam and CO2 on Gasification Tar Composition and Evolution of Aromatic Compounds.

Steam Reforming of Tar Studied in Bench-Scale Experiments and Pilot-Scale Tests with Simulations

Effect of Steam on the Tar Reforming during Circulating Fluidized Bed Char Gasification

Experimental Investigation Of Tar Reduction Properties By Coupling Oxidative Pyrolysis And Partial Oxidation In A Continuous Reactor For Biomass Gasification

Characterization of tar formation during high temperature gasification of different chemical compositions in biomass

Numerical and experimental assessment of parametric effect on steam-carbon dioxide co-gasification of sewage sludge and coal in an updraft reactor

Co-gasification of biomass and polyethylene: a simulation study by considering tar formation

Steam Co-Gasification of Biomass and Coal in Decoupled Reactors

Optimization of Operating Parameters for Tar Reforming/hydrogen Upgrading in Corn Straw Pyrolysis Polygeneration

Effect of steam on coke deposition during the tar reforming from corn straw pyrolysis over biochar

Biomass Steam Gasification for Hydrogen-Rich Gas Production in a Decoupled Dual Loop Gasification System

Experimental and Theoretical Studies on the Conversion of Biomass Pyrolysis Tar under the Effect of Steam

Experimental Study on Catalytic and Thermal Cracking of Tar from Biomass Pyrolysis

Effect of Pressurized Torrefaction Pretreatments on Biomass CO2 Gasification

Modeling Tar Recirculation in Biomass Fluidized Bed Gasification

The evolution and formation of tar species in a downdraft gasifier: Numerical modelling and experimental validation

Torrefaction Integrated with Steam Gasification of Agricultural Biomass Wastes for Enhancing Tar Reduction and Hydrogen-Rich Syngas Production

Plasma reforming of tar model compound in a rotating gliding arc reactor: Understanding the effects of CO<sub>2</sub> and H<sub>2</sub>O addition

Effect of CO 2 Atmosphere on Biomass Pyrolysis and In‐line Catalytic Reforming