Abstract:Anaerobic digestion (AD) with prestage hydrothermal treatment (HT) is an emerging strategy for the sustainable management of sewage sludge and recovery of valuable resources. Both struvite and vivianite can be precipitated during AD process and serve as two important phases for phosphorus (P) and/or nitrogen (N) recovery. Yet the effect of HT conditions on the phase selection and precipitation of struvite vs vivianite in the subsequent AD process remains unclear. This study investigated the evolution and mineralization of P and N in sewage sludge during AD with prestage HT using complementary chemical extraction and X-ray spectroscopy characterizations. Influencing factors such as sludge type and HT temperature were explored. For raw sludge with high molar ratio of Mg/Fe (5.9), HT did not induce the formation of struvite in the HT-derived hydrochars, because the acidic pH of HT slurries was similar to that in the raw sludge. Struvite was observed during the AD of low temperature (90 and 125 °C) HT slurries due to the reaction of Mg-phosphate phases with high concentration of NH4+ at pH > 7. For HT slurries prepared at 155 °C, the pH was always below 7 during the subsequent AD process, preventing struvite precipitation in the AD solids. For raw sludge with low molar ratio of Mg/Fe (1.1), HT at 90 and 125 °C induced the formation of vivianite in the hydrochars, as compared to the formation of strengite at 155 °C HT. In comparison with the corresponding hydrochars, more vivianite was precipitated during the subsequent AD via microbial reduction of Fe(III) species. Results from this study suggest that the formation of struvite or vivianite in the final AD solids is highly dependent on the Mg/Fe molar ratio and/or the pH of AD suspensions. Meanwhile, both HT and AD also strongly affected N speciation evolution in sewage sludge. Along with the release of large amounts of ammonia, HT favored the accumulation of quaternary- and pyrrole-N in the hydrochars, while only pyrrole-N was enriched in the AD solids. This study sheds light on the recycling and reclamation of P and N during HT-AD of sewage sludge.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acssuschemeng.1c02638?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acssuschemeng.1c02638</a>.P standard compounds for P K-edge XANES analysis; analysis of the major metal concentrations, total P, and total N in the solids; analysis of the major metal concentrations, PO43–, and NH4+ in process waters; analysis of extracted P and NH4+ in the solids; results of P K-edge XANES analysis; and results of N 1s XPS analysis (<a class="ext-link" href="/doi/suppl/10.1021/acssuschemeng.1c02638/suppl_file/sc1c02638_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Effect of Interstage Hydrothermal Treatment on Anaerobic Digestion of Sewage Sludge: Speciation Evolution of Phosphorus, Iron, and Sulfur

Coevolution of Iron, Phosphorus, and Sulfur Speciation during Anaerobic Digestion with Hydrothermal Pretreatment of Sewage Sludge

Effect of Prestage Hydrothermal Treatment on the Formation of Struvite vs Vivianite during Semicontinuous Anaerobic Digestion of Sewage Sludge

Transformation and Mobility of Cu, Zn, and Cr in Sewage Sludge during Anaerobic Digestion with Pre- or Interstage Hydrothermal Treatment

Transformation Kinetics of Phosphorus and Nitrogen in Iron-Rich Sewage Sludges during Hydrothermal Treatment and Recovery of Nutrients from Process Water

Additional ratios of hydrolysates from lignocellulosic digestate at different hydrothermal temperatures influencing anaerobic digestion performance

Enhancing Phosphorus Release from Sewage Sludge in Anaerobic Digestion via Thermal Hydrolysis Pretreatment: Insights from Phosphorus Speciation and Molecular Biological Pathways

Evolution of phosphorus complexation and mineralogy during (hydro)thermal treatments of activated and anaerobically digested sludge: Insights from sequential extraction and P K-edge XANES

A comparative study on biogas production, energy balance, and nutrients conversion with inter-stage hydrothermal treatment of sewage sludge

Anaerobic digestion of hydrothermally pretreated dewatered sewage sludge: effects of process conditions on methane production and the fate of phosphorus

Molecular understanding of speciation transformation of phosphorus and sulfur in food waste digestate during hydrothermal treatment

Hydrothermal pretreatment of sewage sludge for enhanced anaerobic digestion: Resource transformation and energy balance

Speciation Evolution of Phosphorus and Sulfur Derived from Sewage Sludge Biochar in Soil: Ageing Effects

Effect of iron sources on methane production and phosphorous transformation in an anaerobic digestion system of waste activated sludge

Revealing the variations in physicochemical, morphological, fractal, and rheological properties of digestate during the mesophilic anaerobic digestion of iron-rich waste activated sludge

Sludge composition and characteristics shaped microbial community and further determined process performance: A study on full-scale thermal hydrolysis-anaerobic digestion processes

High-solid anaerobic digestion of sewage sludge: achievements and perspectives

Variations of heavy metals, nutrients, POPs and particle size distribution during “sludge anaerobic digestion-solar drying-land utilization process”: Case study in China

Transformation of Phosphorus during Low-Temperature Co-Combustion of Sewage Sludge with Biowastes

Dewaterability enhancement and heavy metals immobilization by pig manure biochar addition during hydrothermal treatment of sewage sludge

New insight into volatile sulfur compounds conversion in anaerobic digestion of excess sludge: Influence of free ammonia nitrogen and thermal hydrolysis pretreatment