Abstract:Organic matter and nutrients present in urban and industrial wastewater should be removed or valorised to reduce its impact on the environment. Conventional wastewater treatments are focused on the removal of these pollution sources at the minimum cost. The idea of resource recovery from wastewater is changing the concept of the conventional wastewater treatment plants that tend to incorporate little by little processes as anaerobic digestion, MBR, biofilm, granulation, etc. However, their application to obtain reusable by-products from wastes should be cost effective. Winery wastewater is an effluent with a highly biodegradable organic load, worth considering for biogas production, and low nutrient content. A sidestream anaerobic membrane bioreactor (AnMBR) was started up and operated under organic load oscillations. The stable operation was assured by keeping a ratio between intermediate alkalinity and total alkalinity (IA/TA) below 0.3 achieving a 96.7±2.7% COD removal efficiency. The biogas production varied according with the OLR that was on average 0.50±0.17 m(3)(biogas)/m(-3)(digester)/d(-1) with an 87.1±3.0% of methane. The external membrane module reached a flux of 20.2 ± 8.5 LMH at a crossflow velocity of 0.64 m s-1. The crossflow velocity helped to remove the cake layer attached on the membrane that was the main contribution (>80%) to flux decline. The energy demand of the AnMBR was calculated considering the net energy production of a combined heat and power (CHP) unit. It was concluded that only when influent COD was over 3.25 gCOD 1:1- the energy balance was positive. Considering the upscaling of the AnMBR of the present study, the submerged membrane configuration would be a more feasible option due to its lower operational costs, especially in winter season. Simulating the conditions of winter season, winery wastewater was treated in the AnMBR at low temperatures of 25°C and 15°C. Since the organic load of winery wastewater in winter is much lower than in summer (vintage season), the average OLR applied was 0.32 and 0.29 kgCOD m(-3)(digester)/d(-1) the average COD removal reached was 80% and 71% at 25°C and 15°C., respectively. Moreover, higher degree of fouling was observed despite the amount of suspended solids was lower, so frequent cleanings were necessary. The effluent of anaerobic digestion often requires a post-treatment to remove nutrients, especially nitrogen. Compared with conventional biological nitrogen removal, nitritation/denitritation (N/DN) via nitrite represent a 25% less aeration and 40% less external carbon source. In order to reach higher flexibility and reducing space requirements, N/DN can be carried out in a sequencing batch reactor (SBR). Under feast and famine conditions applied in the SBR, storage compounds can be served as internal carbon sources for post-anoxic denitrification. A novel scheme was developed for the treatment of municipal wastewater; consisting in an UASB reactor followed by a short cut sequencing batch reactor (scSBR) in the main water line. Nitritation/denitritation was integrated with the selection of polyhydroxyalkanoate (PHA) storing biomass. Biowaste fermented liquid was applied as carbon source in the feast regime. The average nitrogen removal was 83%. After achieving an acceptable ammonia removal of 93%, there was enough available PHA for the subsequent denitritation, reaching a maximum nitrite removal of 98%. The maximum PHA content was 10.6% (gPHA gTSS-1) after 10 h of accumulation when biowaste fermented liquid (C/N/P= 100/4.5/0.42) was applied. Nitrogen removal limits could be successfully met while PHA-storing biomass was selected. Although higher PHA yields can be achieved under complete aerobic conditions, this novel scheme presents an added value due to the integration of the PHA production in the nitritation/denitritation process.

Nitrogen removal from aquaculture pond water by heterotrophic nitrogen assimilation in lab-scale sequencing batch reactors

Simultaneous Ammonia and Nitrate Removal in an Airlift Reactor Using Poly(butylene Succinate) As Carbon Source and Biofilm Carrier.

Characterization of Simultaneous Ammonium and Nitrate Removal and Microbial Communities in Airlift Reactor Using 3-Hydroxybutyrate-co-3-hydroxyvalerate (PHBV) As Carbon Source and Biofilm Carrier.

Denitrification performance and bacterial ecological network of a reactor using biodegradable poly(3-hydroxybutyrate-co-3-hydroxyvalerate) as an electron donor for nitrate removal from aquaculture wastewater

Using Poly(β-Hydroxybutyrate-β-hydroxyvalerate) As Carbon Source in Biofloc-Systems: Nitrogen Dynamics and Shift of Oreochromis Niloticus Gut Microbiota.

Biological Denitrification Using Poly(Butylene Succinate) As Carbon Source and Biofilm Carrier for Recirculating Aquaculture System Effluent Treatment

Investigating the conversion from nitrifying to denitrifying water-treatment efficiencies of the biofloc biofilter in a recirculating aquaculture system

Enhanced ammonium removal from liquid anaerobic digestion residuals in an advanced sequencing batch reactor system

Optimization of Wastewater Treatment in a Sequential Fluidized Bed Bioreactor

Influence of the C/N ratio on the performance of polyhydroxybutyrate (PHB) producing sequencing batch reactors at short SRTs

Study of nitrogen and organics removal in sequencing batch reactor (SBR) using hybrid media

A contribution to resource recovery from wastewater. Anaerobic processes for organic matter and nitrogen treatment

Simultaneous Removal of Nitrogen and Phosphorus from Swine Wastewater in a Sequencing Batch Biofilm Reactor

Influence of Aeration Rate on Uncoupled Fed Mixed Microbial Cultures for Polyhydroxybutyrate Production

Study on the flocs poly-β-hydroxybutyrate production and process optimization in the bio-flocs technology system.

Impact of nitrogen feeding regulation on polyhydroxyalkanoates production by mixed microbial cultures

Nitrogen Removal Performance of Novel Isolated Bacillus sp. Capable of Simultaneous Heterotrophic Nitrification and Aerobic Denitrification

Effective nitrogen removal from onsite wastewater using a sequencing aerated biofilm reactor

Increasing fish production in recirculating aquaculture system by integrating a biofloc-worm reactor for protein recovery

Microbial nitrogen removal in synthetic aquaculture wastewater by fixed-bed baffled reactors packed with different biofilm carrier materials

Biological phosphorus and nitrogen removal in a sequencing batch moving bed biofilm reactor