Abstract:Treating hydroxyapatite (HAP) with sulfonic acid without structural destruction remains challenging owing to the sensitivity of HAP to acidic pH. In this work, natural derived HAP was prepared using natural phosphate via a dissolution/precipitation process. Notwithstanding the challenge, the prepared HAP was treated with three concentrations of chlorosulfonic acid in dichloromethane to prepare HAP-S1, HAP-S2 and HAP-S3 depending on the acid content under carefully controlled conditions. The treatment of HAP with the lowest acid concentration led to the preservation of the apatite framework with surface modification of sulfonic acid groups. As the acid concentration increased, HAP, CaHPO4 and CaSO4 were obtained. A further increase in the acid concentration led to the formation of CaSO4 with the coexistence of Ca(H2PO4)2·H2O. Subsequently, the catalytic activity of HAP-S1 was evaluated in oleic acid esterification under microwave irradiation, resulting in a yield of up to 87% under optimized conditions of 10 wt% of catalyst to oleic acid weight, 10 : 1 methanol to oleic acid molar ratio, and 40 min reaction duration under microwave irradiation at 150 °C. The activity of HAP-S1 was attributed to the active S[double bond, length as m-dash]O and S-O-H functional groups, and a possible mechanism of acid-catalyzed esterification is proposed. The catalyst was also tested in the transesterification reaction of rapeseed oil, achieving a conversion of 40.2% after 60 min reaction duration under microwave irradiation. Furthermore, the catalyst was evaluated in a two-step esterification reaction to investigate its activity towards acidified feedstocks. Results showed that after two successive runs, acidity was reduced by 79.6% with a total FAME yield of 40.13%. The obtained results indicate that this catalyst, being an acid catalyst, is more suitable for direct esterification.

Ultrasound assisted enzymatic conversion of non edible oil to methyl esters

In Situ Ethyl Ester Production from Wet Algal Biomass under Microwave-Mediated Supercritical Ethanol Conditions

Ultrasound assisted enzymatic degumming of crude soybean oil

Ultrasound-assisted chemoenzymatic epoxidation of soybean oil by using lipase as biocatalyst

A novel rapid ultrasonication-microwave treatment for total lipid extraction from wet oleaginous yeast biomass for sustainable biodiesel production

Enhancement of hydrodynamic cavitation in the esterification reaction of soybean oil deodorizer distillate

Enhancing efficiency of ultrasound-assisted biodiesel production catalyzed by Eversa® Transform 2.0 at low lipase concentration: Enzyme characterization and process optimization

Ultrasound affects the selectivity and activity of immobilized lipases applied to fatty acid ethyl ester synthesis

Fatty acids methyl esters from vegetable oil by means of ultrasonic energy

Intensification of the Enzymatic Esterification Process by Ultrasounds

Enzyme-catalysed production of n-butyl palmitate using ultrasound-assisted esterification of palmitic acid in a solvent-free system

Epoxidation of Fatty Acid Methyle Ester with hydrodynamic cavitation technology

Study on Influences of Improving the Conversion Degree of Fatty Acid Methyl Ester by Using Chemical and Ultrasonic Methods in the NaOCH_3 Catalyzed System

Transesterification of Waste Frying Oil and Soybean Oil by Combi-lipases Under Ultrasound-Assisted Reactions

Intensified synthesis of palm olein designer lipids using sonication

Microwave-driven oleic acid esterification over chlorosulfonic acid-treated hydroxyapatite: synergism for intensified biodiesel production

Lipase-catalyzed Irreversible Transesterification of Vegetable Oils for Fatty Acid Methyl Esters Production with Dimethyl Carbonate As the Acyl Acceptor

Enzymatic Production of Fatty Acid Methyl Esters by Hydrolysis of Acid Oil Followed by Esterification

A parameter study of ultrasound assisted enzymatic esterification

Improvement in lipase-catalyzed synthesis of fatty acid methyl esters from sunflower oil

Optimization of Process Parameters in Preparation of Nanoemulsions of CLnA Rich Oil by Response Surface Methodology