Abstract:Grain sizes, impurities, and layer thicknesses in the nm-range affect the heat transport and, hence, hinder proper heat dissipation of GaN-based devices. To obtain a clear picture of heat dissipation, the mechanisms of heat transport must be linked to the structural properties of the nitride-based materials in the device. In this paper, a systematic investigation of the typical layers of GaN high-electron mobility transistor stacks was conducted by time-domain thermoreflectance analysis and Raman measurements. The analyzed layers are the AlN nucleation layer, the Al0.3Ga0.7N transition layer, the AlGaN/AlN superlattice, the C-doped GaN back-barrier, and the uid GaN layer. The results were interpreted using the Born–van Karman model, including the suppression function approach to describe the governing heat transport mechanisms. Investigation of this AlN nucleation layer showed that its phonon scattering is dominated by impurity and grain boundary scattering. The Al0.3Ga0.7N transition layer was shown to have a reduced thermal conductivity not only due to alloy scattering but also because of grain boundary scattering. The AlGaN/AlN superlattice showed a thermal conductivity lower than the Al0.3Ga0.7N transition layer, especially at higher temperatures (7.2 ± 0.2 W/mK vs 14.1 ± 0.4 W/mK at 300 °C). Caused by the enhanced AlGaN/AlN interface density, the thermal conductance was found to be 2 GW/m2 K. The AlGaN/AlN superlattice indicated an anisotropic thermal transport with a factor of ∼1.5. The C-doped GaN layers were analyzed in terms of their size-dictated thermal conductivity, resulting in a reduction of ∼66% from 1 μm to 250 nm at 30 °C. Raman spectroscopy revealed that the thicker the GaN layer, the higher the compressive stress in GaN, which additionally results in a higher thermal transport. The investigations of the heat transport depending on the structural properties enabled an accurate determination of the thermal conductivity of the layer stack. These thermal conductivities served as input parameters for 3D simulation to extract the temperature, in terms of the thermal resistance, of such high-electron mobility transistor stacks. This simulation shows the importance of the GaN layer in terms of thermal management. This work uncovers the thermal transport in GaN-based transistor stacks with the aim to improving the thermal design.

Heat transfer enhancement of N-Ga-Al semiconductors heterogeneous interfaces

Thermal Stress Analysis and Structural Design of AlxGa1−xN/GaN Epilayers Based on Si Substrate

Effects of Surface/interface Stress on Phonon Properties and Thermal Conductivity in AlN/GaN/AlN Heterostructural Nanofilms

Large “near Junction” Thermal Resistance Reduction in Electronics by Interface Nanoengineering

Phonon transport across rough AlGaN/GaN interfaces with varying Al–Ga atomic ratios

Enhanced Thermal Boundary Conductance across GaN/SiC Interfaces with AlN Transition Layers

Effect of the Alloyed Interlayer on the Thermal Conductance of Al/GaN Interface

Phonon Transport Across GaN/AlN Interface: Interfacial Phonon Modes and Phonon Local Non-Equilibrium Analysis

Deep neural network-based molecular dynamics simulations for AlxGa1-xN alloys and their thermal properties

Thermal transport mechanism of AlN/SiG/3C-SiC typical heterostructures

Modulation of Localized Phonon Thermal Transport at GaN/Al Ga1-N Heterointerface: Polar Surface, Doping, and Compressive Strain

Influence of Ultrathin AlN Interlayer on the Microstructure and the Electrical Transport Properties of AlxGa1−xN/GaN Heterostructures

Significantly Enhanced Interfacial Thermal Conductance across GaN/Diamond Interfaces Utilizing AlxGa1- xN as a Phonon Bridge

Simulation Study of Phonon Transport at the GaN/AlN Superlattice Interface: Ballistic and Non-Equilibrium Phenomena

Correlation of heat transport mechanism and structural properties of GaN high electron mobility transistors

Significantly Enhanced Interfacial Thermal Conductance Across GaN/Diamond Interfaces Utilizing Alx Ga1-x N As a Phonon Bridge

Significantly Enhanced Interfacial Thermal Conductance across GaN/Diamond Interfaces Utilizing Al x Ga 1- x N as a Phonon Bridge

Ni Diffusion and Its Influence on Electrical Properties of AlxGa1−xN∕GaN Heterostructures

The Influence of 1nm AlN Interlayer on Properties of the Al0.3Ga0.7N/AlN/GaN HEMT Structure

Study of the Leakage Current Mechanism in Schottky Contacts to Al0.25Ga0.75N/GaN Heterostructures with AlN Interlayers

Effect of AlN interlayer thickness on leakage currents in Schottky contacts to Alo.25Gao.75N/AlN/GaN heterostructures