Abstract:Coarsening or Oswald ripening, induced by interbubble gas diffusion, is considered to dominate foam structure evolution in porous media. We present the first study of trapped foam coarsening dynamics under realistic deep reservoir conditions (up to 3200 psi/22 MPa of pore pressure and 100 °C of temperature) in a high-pressure and high-temperature microfluidic system. The findings are expected to help predict foam structure evolution in applications such as enhanced oil recovery and CO2 geological sequestration. It is shown that, in porous media, larger bubbles grow at the expense of smaller bubbles. The growth rate of the average bubble area (⟨a⟩) over time shows a long-term linear increase when ⟨a⟩ is between 1/5 and 1/2 of the average pore size. The foam coarsening kinetics are determined by the liquid film permeability, gas-liquid interfacial tension, and the molar volume of the dispersed phase. In summary, foams prepared with less water-soluble gases (e.g., N2 and air) and lower foam quality show slower coarsening kinetics due to a lower film permeability. Foam coarsening is more sensitive to surfactant concentration (than surfactant type), as it determines the interfacial tension that controls the mass transfer driving force (capillary pressure difference). The transport properties of the dispersed phase depend strongly on its density, which increases with increasing pore pressure and decreasing temperature. At the same experimental conditions, gas CO2 foam shows a 10-fold faster coarsening rate than N2 foam. However, dense (i.e., liquid and supercritical) CO2 foams show a remarkable 20-500-fold reduction in coarsening kinetics compared with gas N2 and CO2 foams due to the significantly reduced mass transfer driving forces. In a sense, trapped CO2 foam can be stronger than N2 foam at high-pressure and high-temperature conditions.

Matrix viscoelasticity decouples bubble growth and dynamics in coarsening foams

Matrix Viscoelasticity Decouples Bubble Growth and Mobility in Coarsening Foams

Anomalous relaxation of coarsening foams with viscoelastic continuous phases

Anomalous relaxation of coarsening foams with viscoelastic continuous phase

Viscoelastic coarsening of quasi-2D foam

Foam coarsening in a yield stress fluid

Limiting coarsening of a two-bubble foam with viscosity

Local origin of the visco-elasticity of a millimetric elementary foam

Hierarchical bubble size distributions in coarsening wet liquid foams

Multiscale stress dynamics in sheared liquid foams revealed by tomo-rheoscopy

Influence of density and viscosity on deformation, breakage, and coalescence of bubbles in turbulence

Experimental study on the dynamics and mass transfer of CO2 bubbles rising in viscoelastic fluids

Oscillations of small bubbles and medium yielding in elastoviscoplastic fluids

Multiple dynamic regimes in a coarsening foam

Slow viscoelastic relaxation and aging in aqueous foam

Coalescence of bubbles in a viscoelastic liquid

Coupled elasticity in soft solid foams

Experimental and modeling study of foam coarsening kinetics in porous media

Coarsening and mechanics in the bubble model for wet foams

Microfluidic Investigation of Foam Coarsening Dynamics in Porous Media at High-Pressure and High-Temperature Conditions

Effects of liquid fraction and contact angle on structure and coarsening in two-dimensional foams