Abstract:CO2-expanded organic solvent is a kind of important fluid medium and has broad applications in chemical industry, environmental protection and other fields. Ultrasonic cavitation in gas expanded liquids (GXLs) is conducive to enhancing mass transfer and producing many exciting phenomena. In this paper, the ultrasonic cavitations and streaming in the saturated CO2-expanded liquid N, N-dimethylformamide (DMF) at 4.2 MPa and 5.2 MPa are observed by a high-speed camera. The cavitation intensity and time trace of pressure pulses are recorded using a PZT hydrophone. The influences of gas-liquid equilibrium pressure and ultrasonic power on the cluster dynamics of transient and stable cavitation are examined. The excess molar enthalpies required for CO(2 )dissociation from DMF are calculated by Peng-Robinson equations of state and the change of surface free energy of CO2-expanded DMF is predicted. The results show that the excess enthalpy of the mixture is one of the key factors to control ultrasonic cavitation at high pressurized conditions, while the surface tension is the key factor for low pressure. As the increase of applied ultrasonic power, the formation and collapsing frequency of bubble clusters increases, and the amplitude and cyclic frequency of pressure pulse are enhanced. The transient cavitation intensity increases as it reaches a maximum value at a certain ultrasonic power and then decreases. The change trends of stable cavitation intensity under different pressures are basically same. It can be concluded from the evidence that ultrasonic cavitation in CO2-expanded DMF is affected by the combined effect of compression and substitution: compression depresses the nucleation and growth of bubbles, while the high solubility of CO2 in DMF is conducive to the generation of bubbles in cavitation.

Experimental study on the dynamics and mass transfer of CO2 bubbles rising in viscoelastic fluids

Experimental Measurement and Theoretical Analysis on Bubble Dynamic Behaviors in a Gas-Liquid Bubble Column

Experimental Investigation of the Behaviors of Highly Deformed Bubbles Produced by Coaxial Coalescence

The Influence of Pressure on the Acoustic Cavitation in Saturated CO2-expanded N, N-dimethylformamide

Experimental and Numerical Investigations of Scale-Up Effects on the Hydrodynamics of Slurry Bubble Columns

An experimental study of the dynamics and mass transfer of a rising bubble

Mass transfer dynamics of single CO 2 bubbles rising in monoethanolamine solutions: Experimental study and mathematical model

Dynamics of Bubble Formation in Highly Viscous Liquid in Co-Flowing Microfluidic Device

Experimental study of interfacial mass transfer from single CO2 bubbles ascending in stagnant water

Direct numerical simulation of deformable rising bubbles at low Reynolds numbers

Bubble Removal in Viscoelastic Solution by Ultrasonic Vibration

Three-Dimensional Roll-Up of A Viscoelastic Mixing Layer

Numerical investigation on the bubble rising dynamics in ratchet channels filled with viscoelastic liquids

Experimental study on single CO 2 bubbles freely rising in MEA/DEEA blended solutions: Bubble behavior and mass transfer

Experimental Study on Bubble Dynamics and Mass Transfer Characteristics of Coaxial Bubbles in Petroleum-Based Liquids

Coupling Model of Motion and Mass Transfer in Multicomponent Desorption of Fine Bubbles

Matrix Viscoelasticity Decouples Bubble Growth and Mobility in Coarsening Foams

Dynamics of a single bubble in Newtonian and non-Newtonian fluids: Experimental and simulation approaches

Interactions between cavitation bubbles and free surfaces of non-Newtonian polymer solutions

Experimental study and CFD simulation of mass transfercharacteristics of a gas-induced pulsating flow bubblecolumn

Effect of Liquid Viscosity on Hydrodynamics and Bubble Behaviour of an External‐loop Airlift Reactor