Abstract:The microalgae Haematococcus pluvialis are the main source of the natural antioxidant astaxanthin. However, the effective extraction of astaxanthin from these microalgae remains a significant challenge due to the rigid, non-hydrolyzable cell walls. Energy savings and high-efficiency cell disruption are essential steps in the recovery of the antioxidant astaxanthin from the cysts of H. pluvialis . In the present study, H. pluvialis microalgae were first cultured in Bold's Basal medium under certain conditions to reach the maximum biomass concentration, and then light shock was applied for astaxanthin accumulation. The cells were initially green and oval, with two flagella. As the induction time increases, the motile cells lose their flagellum and become red cysts with thick cell walls. Pre-treatment of aqueous two-phase systems based on deep eutectic solvents was used to decompose the cell wall. These systems included dipotassium hydrogen phosphate salt, water, and two types of deep eutectic solvents (choline chloride–urea and choline chloride–glucose). The results of pre-treatment of Haematococcus cells by the studied systems showed that intact, healthy cysts were significantly ruptured, disrupted, and facilitated the release of cytoplasmic components, thus facilitating the subsequent separation of astaxanthin by liquid–liquid extraction. The system containing the deep eutectic solvent of choline chloride–urea was the most effective system for cell wall degradation, which resulted in the highest ability to extract astaxanthin. More than 99% of astaxanthin was extracted from Haematococcus under mild conditions (35% deep eutectic solvent, 30% dipotassium hydrogen phosphate at 50 °C, pH = 7.5, followed by liquid–liquid extraction at 25 °C). The present study shows that the pre-treatment of two-phase systems based on deep eutectic solvent and, thus, liquid–liquid extraction is an efficient and environmentally friendly process to improve astaxanthin from the microalgae H. pluvialis .

Application of surfactants for controlling destructive fungus contamination in mass cultivation of Haematococcus pluvialis

Controlling of two destructive zooplanktonic predators in Chlorella mass culture with surfactants

Producing cell-free culture broth of rhamnolipids as a cost-effective fungicide against plant pathogens.

Effects of surfactants on production of D-arabitol by Debaryomyces hansenii

Fenton Reaction Facilitates The Fungal Infection On The Unicellular Alga Haematococcus Pluvialis and Discovery of a Biosafe and Environment-Friendly Chemical That Blocks The Infection

Inhibition of Harmful Algae Phaeocystis Globosa and Prorocentrum Donghaiense by Extracts of Coastal Invasive Plant Spartina Alterniflora.

A fed-batch feeding with succinic acid strategy for astaxanthin and lipid hyper-production in Haematococcus pluviualis

Effectiveness of sodium sulfite as an electron acceptor for bioenhanced treatment of salt-containing water produced from ASP flooding

Application of biosurfactant from Bacillus subtilis C9 for controlling cladoceran grazers in algal cultivation systems

Promotion of droplet deposition, diffusion-wetting and retention on hydrophobic surfaces by nonionic star-shaped oligomeric surfactants

Impact of four surfactants on the uptake of per- and polyfluoroalkyl substances (PFAS) by red fescue grass

Screening and Selection of Antibiotics for Enhanced Production of Astaxanthin by Haematococcus lacustris

Fermentation optimization of surfactin production of Bacillus amyloliquefaciens HM618

Using a Novel Hydrogen-Terminated Porous Si Wafer to Enhance Microcystis Aeruginosa Effective Removal by Chitosan at a Low Dosage

Simultaneous Promotion of Photosynthesis and Astaxanthin Accumulation During Two Stages of Haematococcus Pluvialis with Ammonium Ferric Citrate.

Removal of Microcystis Aeruginosa and Control of Algal Organic Matter by Fe(II)/peroxymonosulfate Pre-Oxidation Enhanced Coagulation

Bacillus amyloliquefaciens A-1 inhibiting fungal spoilage in agricultural products is improved by metabolic engineering of enhancing surfactin yield

Extraction and separation of astaxanthin with the help of pre-treatment of Haematococcus pluvialis microalgae biomass using aqueous two-phase systems based on deep eutectic solvents

Ion flotation removal of a range of contaminant ions from drinking water

Insights into using green and unconventional technologies to recover natural astaxanthin from microbial biomass

Increasing production and bio-accessibility of natural astaxanthin in Haematococcus pluvialis by screening and culturing red motile cells under high light condition