Abstract:The critical point is the end point of a phase equilibrium curve; liquid and its vapor can coexist under designated points. Close to the critical point, thermophysical properties present clear variations, especially in the region of 0.85P(cr)similar to P-cr Latent heat and liquid density in this region decrease more quickly than in lower-pressure areas, resulting in unique boiling heat transfer behavior. This region is also called the near-critical region. However, only a few scholars have discussed the heat transfer phenomenon; thus, it is difficult to ascertain the near-critical region's properties and characteristics from extant literature. In the present study, we conduct experimental investigations to explore the specificities of the heat transfer characteristics of carbon dioxide in horizontal flow within the near-critical region in a circular channel with a diameter of 4 mm. The operating pressure ranges from 6.26 MPa to 7.3 MPa with a mass flow rate between 200 and 400 kg/m(2) s, heat flux between 5 and 140 kW/m(2), and test section inlet temperature of -5 degrees C. Then, we examine the inner-wall temperature and heat transfer coefficient profiles at different pressures within the near-critical region. The results show that at high heat flux, departure from nucleate boiling (DNB) phenomenon presents with a sudden decrease in the heat transfer coefficient in the sub cooled region. The higher the heat flux, the more seriously deteriorating the heat transfer is. Interestingly, the temperature reaches its peak in the post-DNB region rather than at the critical vapor quality point. With an increase in pressure, DNB occurs early with lower vapor quality, and the temperature peak decreases at the given heat flux and mass flux. On the contrary, DNB is delayed with an increase in mass flux. A series of boiling heat transfer correlations in a subcooled region, two-phase flow region, and superheated region are proposed in addition to a new predictive correlation for critical heat flux in the near-critical region at a given mass flux. (C) 2018 Elsevier Ltd. All rights reserved.

Pseudophase-Change Effects in Turbulent Channel Flow under Transcritical Temperature Conditions

Equivalence of Three Thermal Boundary Conditions in Compressible Turbulent Channel Flows

Direct Numerical Simulation of Stably-Stratified Turbulent Channel Flow with CO<Subscript>2</Subscript> Supercritical Pressure

Mean Velocity and Temperature Scaling for Near-Wall Turbulence with Heat Transfer at Supercritical Pressure

Vortical Structures and Turbulence Characteristics in an Isothermal Channel Flow at Supercritical Pressure

Analysis of Real-Fluid Thermodynamic Effects on Turbulent Statistics in Transcritical Channel Flows

Direct Numerical Simulation of Coherent Structure in Turbulent Open-Channel Flows with Heat Transfer

Direct Numerical Simulations of K-type transition in a flat-plate boundary layer with supercritical fluids

Numerical Model Development for Critical Region Flow and Thermodynamic Transitions of CO2 Fluids in Microchannel

Transient growth in diabatic boundary layers with fluids at supercritical pressure

Experimental Investigations on the Boiling Heat Transfer of Horizontal Flow in the Near-Critical Region

Numerical Study of Compressible Wall-Bounded Turbulence – the Effect of Thermal Wall Conditions on the Turbulent Prandtl Number in the Low-Supersonic Regime

Comparisons of Temperature Structures with Turbulent Structures in Thermally Stratified Channel Flows by Direct Numerical Simulation

Direct numerical simulations of compressible turbulent channel flows with asymmetric thermal walls

Direct Numerical Simulation of Compressible Turbulent Channel Flows over Porous Boundaries

Numerical Simulation of Stability Behaviors and Heat Transfer Characteristics for Near-Critical Fluid Microchannel Flows

Experimental Investigation on Flow Regimes and Transitions of Steam-Water Two-Phase Flow in Narrow Rectangular Horizontal Channels

Microconfined high-pressure transcritical fluids turbulence

Turbulence in a Heated Pipe at Supercritical Pressure

Buoyancy-induced Flows and Phase-Change Heat Transfer in a Vertical Capillary Structure with Symmetric Heating

Insights into the dynamics of supercritical water flow using a two-phase approach