Combined free-stream disturbance measurements and receptivity studies in hypersonic wind tunnels by means of a slender wedge probe and DNS

Alexander Wagner,Erich Schülein,René Petervari,Klaus Hannemann,Syed R. C. Ali,Adriano Cerminara,Neil D. Sandham

DOI: https://doi.org/10.1017/jfm.2018.132

2017-05-31

Abstract:Combined free-stream disturbance measurements and receptivity studies in hypersonic wind tunnels were conducted by means of a slender wedge probe and direct numerical simulation. The study comprises comparative tunnel noise measurements at Mach 3, 6 and 7.4 in two Ludwieg tube facilities and a shock tunnel. Surface pressure fluctuations were measured over a wide range of frequencies and test conditions including harsh test environments not accessible to measurement techniques such as pitot probes and hot-wire anemometry. Quantitative results of the tunnel noise are provided in frequency ranges relevant for hypersonic boundary layer transition. In combination with the experimental studies, direct numerical simulations of the leading-edge receptivity to fast and slow acoustic waves were performed for the slender wedge probe at conditions corresponding to the experimental free-stream conditions. The receptivity to fast acoustic waves was found to be characterized by an early amplification of the induced fast mode. For slow acoustic waves an initial decay was found close to the leading edge. At all Mach numbers, and for all considered frequencies, the leading-edge receptivity to fast acoustic waves was found to be higher than the receptivity to slow acoustic waves. Further, the effect of inclination angles of the acoustic wave with respect to the flow direction was investigated. The combined numerical and experimental approach in the present study confirmed the previous suggestion that the slow acoustic wave is the dominant acoustic mode in noisy hypersonic wind tunnels.

Fluid Dynamics

What problem does this paper attempt to address?

The problem that this paper attempts to solve is: in a hypersonic wind tunnel, the influence of free - stream disturbances on the boundary - layer transition process. Specifically, the research aims to measure and analyze the free - stream disturbances in a hypersonic wind tunnel and their response characteristics to the boundary - layer transition by using slender - wedge probes and direct numerical simulation (DNS), combining experimental and numerical methods.

### Research Background and Problem Description

1. **Importance of Free - Stream Disturbances**
- Free - stream disturbances play a crucial role in the hypersonic boundary - layer transition process. Understanding this process is essential for the design of aircraft operating under hypersonic conditions. Uncertainties in transition prediction directly lead to uncertainties in the estimation of viscous drag and surface heat flux, and these parameters are key parameters in the design of hypersonic aircraft.

2. **Limitations of Existing Technologies**
- Currently, techniques for measuring free - stream disturbances in hypersonic wind tunnels (such as Pitot probes, hot - wire anemometers, etc.) have many limitations, especially in short - time - pulse facilities and high - temperature environments. These techniques are either unable to measure high - frequency components or are easily damaged in harsh test environments.

3. **Research Objectives**
- This research aims to introduce a new slender - wedge probe that can measure free - stream disturbances in a hypersonic wind tunnel over a wide frequency range, especially suitable for hypersonic shock tubes with harsh test environments. At the same time, the response characteristics of the wedge probe to fast and slow acoustic waves are studied through direct numerical simulation (DNS).

### Research Methods

1. **Experimental Part**
- Experiments are carried out in three different hypersonic wind tunnels using slender - wedge probes, including the DLR High - Enthalpy Shock Tube (HEG), the DNW Ludwieg Tube (RWG), and the Ludwieg Tube at the Technical University of Braunschweig (HLB). The experiments cover Mach 3, 6, and 7.4 conditions.
- Surface pressure fluctuations in different frequency ranges are measured and compared with the results of traditional Pitot probes and hot - wire anemometers.

2. **Numerical Simulation Part**
- The response characteristics of the wedge probe to fast and slow acoustic waves are studied through direct numerical simulation (DNS). The simulation considers acoustic waves with different frequencies and incident angles to evaluate their influence on the boundary - layer transition.

### Main Findings

1. **Experimental Results**
- The slender - wedge probe shows good measurement performance over a wide frequency range, especially superior to traditional techniques in the measurement of high - frequency components.
- The experimental results are consistent with the measurement results of Pitot probes and hot - wire anemometers, verifying the effectiveness of the wedge probe.

2. **Numerical Simulation Results**
- Fast acoustic waves show early amplification characteristics near the leading edge of the wedge probe, while slow acoustic waves show initial attenuation.
- For all Mach numbers and frequencies, the leading - edge response of fast acoustic waves is always higher than that of slow acoustic waves.
- The incident angle of the acoustic wave has a significant influence on the response of fast acoustic waves. Increasing the incident angle will enhance the response on the wave - front side and weaken the response on the opposite side.

### Conclusion

This research successfully characterizes the free - stream disturbances in a hypersonic wind tunnel by combining experiments and numerical simulations, and reveals the different influences of fast and slow acoustic waves on the boundary - layer transition. The research results provide an important reference basis for the design of hypersonic aircraft, especially in transition prediction and reducing uncertainties.