Abstract:Irradiation‐induced charge trapping in defects affects subcritical cracking in 5 mol% yttria‐stabilized zirconia. The formation of microcracks, resulting from charge detrapping during crack propagation, enhances fracture resistance in the subcritical cracking regime by consuming energy through interactions with the main crack. Exposure to ionizing radiation has been known to affect the mechanical properties of solids; however, the exact mechanisms remain debated. In this study, we test the hypothesis that long lived metastable states formed by trapping of charges within defects influence subcritical cracking (SCC). Crack propagation rates were measured in 5 mol% Yttria‐stabilized zirconia samples, with and without prior exposure to Co‐60 gamma radiation (10 kGy absorbed dose). Crack growth was followed in situ by employing a double cantilever beam specimen inside an environmental scanning electron microscope (ESEM). In comparison with the unirradiated samples, an increased energy release rate of ∼10 J/m2 was required to maintain SCC in the irradiated samples conforming to an increase in SCC fracture resistance. Raman and x‐ray studies preclude any phase transformation and volume change due to irradiation; however, there was a significant change in optical absorption characteristics observed as the darkening of the irradiated sample. Thermally and optically stimulated luminescence measurements suggest that sample darkening is caused by metastable states that form due to charge trapping during radiation exposure. A closer examination of the SEM images demonstrates an increased number of microcracks ahead of the main crack in the irradiated specimens. We conclude that charge trapping in defects due to irradiation, and subsequent detrapping during crack propagation by mechanical stresses, initiate the formation of these microcracks. Consequently, energy is consumed during the interactions between the main crack and the developing microcracks, ultimately ensuing an overall increase in fracture resistance in the SCC regime.

Radiation damage and recovery of crystals:Frenkel vs. Schottky defect production

New principles of radiation damage and recovery based on the radiation induced emission of Schottky defects

Radiation damage as a source of information

Radiation Damage in Nanostructured Materials

The kinetics of formation and the parameters of radiation defect clusters in silicon

Radiation Induced Electrical Degradation in Crystalline Al2O3: a Bulk Effect

Structural Damage and Recrystallization Response of Garnet Crystals to Intense Electronic Excitation (Adv. Funct. Mater. 8/2023)

Mapping electron beam-induced radiolytic damage in molecular crystals

Void Growth and Coalescence in Triaxial Stress Fields in Irradiated Fcc Single Crystals

Radiation damage effects in amorphous zirconolite

Effect of Radiation Dose on the Deformation Behavior of the Single-Crystal Fe–10Ni–20Cr Alloy

Computer Modeling of Radiationally and Thermally Stimulated Processes in a Crystal

Fast low-temperature irradiation creep driven by athermal defect dynamics

A multiscale and multiphysics framework to simulate radiation damage in nano-crystalline materials

Atomistic simulations of athermal irradiation creep and swelling of copper and tungsten in the high dose limit

Grain Boundary Defect Production during Successive Displacement Cascades on a Tungsten Surface

Effects of collision cascades on recombination and clustering of point defects

The Evolution of Structural Defects under Irradiation in W by Molecular Dynamics Simulation

Does charge trapping affect subcritical crack growth behavior of yttria‐stabilized zirconia?

Molecular dynamics simulations of irradiated defect clusters evolution in different crystal structures

Responsibility of small defects for the low radiation tolerance of coated conductors.