Abstract:This research paper explores biogas production in an underground temperature-controlled fixed dome digester and compares it with a similar uncontrolled digester. Two underground fixed-dome digesters, one fitted with a solar heating system and a stirrer and the other one with an identical stirrer only, were batch-fed with cow dung slurry collected from the University of Fort Hare farm and mixed with water in a ratio of 1:1. The solar heating system consisted of a solar geyser, pex-al-pex tubing, an electric ball valve, a water circulation pump, an Arduino aided temperature control system, and a heat exchanger located at the centre of the digester. Both the digesters were intermittently stirred for 10 min every 4 h. The digester without a heating system was used as a control. Biogas production in the two digesters was compared to assess the effect of solar heating on biogas production. The total solids, volatile solids, and the chemical oxygen demand of the cow dung used as substrate were determined before and after digestion. These were compared together with the cumulative biogas produced and the methane content for the controlled and uncontrolled digesters. It was observed that the temperature control system kept the slurry temperature in the controlled digester within the required range for 82.76% of the retention period, showing an efficiency of 82.76%. Some maximum temperature gradients of 7.0 °C were observed in both the controlled and uncontrolled digesters, showing that the stirrer speed of 30 rpm was not fast enough to create the needed vortex for a uniform mix in the slurry. It was further observed that the heat from the solar geyser and the ground insulation were sufficient to keep the digester temperature within the required temperature range without any additional heat source even at night. Biogas yield was observed to depend on the pH with a strong coefficient of determination of 0.788 and 0.755 for the controlled and uncontrolled digesters, respectively. The cumulative biogas was 26.77 m3 and 18.05 m3 for controlled and uncontrolled digesters, respectively, which was an increase of 33%. The methane content increased by 14% while carbon dioxide decreased by 10% from the uncontrolled to the controlled scenario. The percentage removal of the TS, VS, and COD was 66.26%, 76.81%, and 74.69%, respectively, compared to 47.01%, 60.37%, and 57.86% for the uncontrolled situation. Thus, the percentage removal of TS, VS, and COD increased by 19.25%, 16.44%, and 16.89%, respectively.

Design and evaluation of a gas, temperature profiling and data acquisition system to monitor the performance of a batch fixed dome biogas digester

Examining A Hybrid Plug-Flow Pilot Reactor Foranaerobic Digestion of Farm-Based Biodegradable Solids

Biogas Production from a Solar-Heated Temperature-Controlled Biogas Digester

An experimental investigation on PV-assisted temperature regulation of biogas plant

ANN-based sensorless adaptive temperature control system to improve methane yield in an anaerobic digester

Design and numerical analysis of a composite system of a household biogas digester with pretreatment

Energy management for maintaining anaerobic digestion temperature in biogas plants

Performance and Microbial Community Evaluation of Full-Scale Two-Phase Anaerobic Digestion of Waste Activated Sludge.

Automatic Carbon Dioxide-Methane Gas Sensor Based on the Solubility of Gases in Water

Pilot-Scale Anaerobic Digestion of Pig Manure with Thermal Pretreatment: Stability Monitoring to Improve the Potential for Obtaining Methane

Designing and performance evaluation of continuously stirring anaerobic batch reactor for biomethane production from biowaste

Online monitoring of gas transfer rates during CO and CO/H2 gas fermentation in quasi-continuously ventilated shake flasks

Enhanced Biogas Purification Using Low-Cost Adsorption and Absorption Techniques

Assessment of demand consumptions and potential viability of installation of biogas digester in melani village Eastern Cape, South Africa

Integration of anaerobic digestion with heat Pump: Machine learning-based technical and environmental assessment

A New Degassing Membrane Coupled Upflow Anaerobic Sludge Blanket (UASB) Reactor to Achieve In-Situ Biogas Upgrading and Recovery of Dissolved CH4 from the Anaerobic Effluent

Real-world assessment of a decentralized food waste anaerobic digestion system: A test-bedding case study application

The temperature and pressure Remote intelligent control system for biogas digester based on STM32

Effect of Temperature Variation on Codigestion of Animal Waste and Agricultural Residue for Biogas Production

Development and Performance Evaluation of Biomass-Based Injera Baking Gasifier Stove: A Case Study of Clean Cooking Technologies in Ethiopia

Online monitoring of methane transfer rates unveils nitrogen fixation dynamics in Methylococcus capsulatus