Abstract:The single crystalline of the prototype Ni-Mn-Ga ferromagnetic shape memory alloy exhibits a huge magnetic field-induced strain of 6% due to the re-orientation of twin variants. Therefore, it is promising as the magneto-driven actuator material. However, the magnetic field or mechanical stress applied along the orthogonal direction is necessary to restore the deformed bulk single crystal into the original shape. In order to avoid an application of the extra fields, the Ni-Mn-Ga particles/polymer composite is an alternative solution supported by the concept of the accumulated stress in a polymer matrix which drives a deformation recovery of the composite during switching off of the magnetic field. The objective of this study is to clarify the effect of embedded particle shape on the deformation recovery of Ni-Mn-Ga particles/silicone composites by using the finite element method (FEM) and to investigate the local stress distribution in a polymer matrix between either spherical or rectangular shape particles pairs, whereby to provide the guidelines for design/optimization of the magneto-strain-active Ni-Mn-Ga particles/polymer composites. The case studies of the simulation are divided into an isolated particle and a pair of particles, the particles being positioned either parallel or perpendicular to the applied magnetic field direction. Particularly, the simulations reveal that in case of 200 μm of the inter-particle distance in the pair of spherical particles aligned perpendicularly to the applied field, the polymer layer between particles generates the compressive recovery stress of -0.32 MPa, which is insufficient to restore the deformation of the embedded Ni-Mn-Ga particles during removal of the magnetic field. By contrast, the strain recovery effect can be achieved for the rectangular particle pairs, generating the stress concentration in a matrix of about -0.5MPa, in a similar condition and arrangement.

Effect of mechanical stresses on coercive force and saturation remanence of ensemble of dual-phase interacting nanoparticles

Effect of mechanical stresses on the coercive force of the heterophase non-interacting nanoparticles

Exploring Stress-Dependent Impedance Behavior Via Magnetization Dynamics in Amorphous Magnetic Fibers in High Frequency: Experimental and Modeling

Ferromagnetic Composite with Stress-Insensitive Magnetic Permeability: Compensation of Stress-Induced Anisotropies

Influence of amorphous phase on coercivity in SmCo5-Cu nanocomposites

Micromagnetic modeling studies on the effects of stress on magnetization reversal and dynamic hysteresis

Prediction of the Magnetotoroidic Effect from Atomistic Simulations

Modeling the magnetostriction effect in elastomers with magnetically soft and hard particles

Effect of interfacial stress on microchemistry and coercivity in 2:17-type SmCo sintered magnets

Strong Enhancement of Magnetic Coercivity Induced by Uniaxial Stress

Simulation on the openness in recoil loop of nanocomposite magnet

The Effect of Particle Shape on Magnetic Field-Induced Rubber-Like Behavior of Ni-Mn-Ga/Silicone Composites

Magneto-induced stress enhancing effect in a colloidal suspension of paramagnetic and superparamagnetic particles dispersed in a ferrofluid medium.

Effect of stress on the magnetic Barkhausen noise energy cycles: A route for stress evaluation in ferromagnetic materials

Strain and Exchange‐Spring Mechanism of (1‐x) Ni0.5Cu0.25Zn0.25Fe2O4 + (x) SrFe11Y1O19 Magnetically Soft–Hard Ferrite Composed Nanoparticles

Simultaneous effects of surface spins: rarely large coercivity, high remanence magnetization and jumps in the hysteresis loops observed in CoFe2O4 nanoparticles.

Magnetorheology and magnetostriction of isolated chains of nonlinear magnetizable spheres

Magnetomechanical coupling and ferromagnetic resonance in magnetic nanoparticles

Magnetostrictive Behavior of Severe Plastically Deformed Nanocrystalline Fe-Cu Materials

Strain Induced Anisotropic Magnetic Behaviour and Exchange Coupling Effect in Fe-SmCo$_{5}$ Permanent Magnets Generated by High Pressure Torsion

Magnetic irreversibility and relaxation in assembly of ferromagnetic nanoparticles