Abstract:Si is emerging as one of the most prospective anode materials for all-solid-state Li-ion batteries due to its extremely high theoretical capacity density of 4200 mAh g -1 and relatively negative potential for lithiation/delithiation. Towards its widespread use, controlling severe volume expansion/contraction during lithiation/delithiation is a challenge because it may cause cracking, fracture, and pulverization that negatively influence the cycle performance and rate capability of the cells [1]. Such mechanical event is induced by the change in the lattice structure due to the formation of Li x Si and successive increasing/decreasing of Li content x in Li x Si [2]. Bimodal atomic force microscopy (AFM) offers quantitative mapping of nanoscale mechanical property, simultaneously with surface topography imaging [3]. Our group previously applied this technique to the cross-section of a composite electrode consist of active materials, binders, conductive additives, and deposited electrolyte solution and successfully demonstrated nanomechanical mapping [4]. Here, we develop an operando bimodal AFM system to track Young’s modulus changes of electrode materials in an all-solid-state battery configuration during the lithiation and delithiation reactions in real-time. A cell in a Cu/Si/LLZT/In/Li configuration was fabricated as follows; a 3 μm-thick Si thin-film and a 100 nm-thick Cu layer were sputter-deposited on one side of Li 6.6 La 3 Zr 1.6 Ta 0.4 O 12 (LLZT) solid electrolyte, an In layer was sputter-deposited on the other side of LLZT, the Cu/Si/LLZT/In sample was milled with an Ar-ion beam to yield a flat and smooth cross-section suitable for AFM analysis, and then a 50 μm-thick Li metal foil was combined with the pre-coated In thin layer. Operando nanomechanical mapping was performed by mounting the cross-section-exposed cell in the custom-made sample holder coupled with a potentiostat for bias applications, in an Ar-filled glove box to prevent any atmospheric influences. Electrochemical lithiation and delithiation were carried out within a potential window of 0.01-1.20 V vs. Li/Li + . Electrochemical characterization indicated that the capacities of the Si electrode for the first lithiation and delithiation are 3300 and 1833 mAh g -1 , respectively. These capacities are equal to the formation of Li 3.46 Si after the first lithiation of the pristine Si and Li 1.54 Si after the successive delithiation from Li 3.46 Si. Throughout the lithiation, the averaged Young’s modulus of Si electrode decreased due to the formation of Li x Si and increase in the Li content x in Li x Si. In the initial stage of lithiation, it drastically decreased because Li x Si was formed by the lithiation of pristine Si. Then, it moderately decreased with increasing Li content x in Li x Si. Unfortunately, the Young’s modulus maps were only recorded until the formation of Li 1.54 Si because the successive delithiation was not completed possibly due to the phase transformation of crystalline Li x Si to amorphous Li x Si [5], which may cause a significant mechanical strain inside the thin film. The measured Young’s modulus values were consistent with those obtained by first principle calculation [6]. Further details are given at the presentation. References: J. Zhong, T. Wang, L. Wang, L. Peng, S. Fu, M. Zhang, J. Cao, X. Xu, J. Liang, H. Fei, X. Duan, B. Lu, Y. Wang, J. Zhu and X. Duan, Nano-Micro Letters , 14 , 50 (2022). M. T. McDowell, S. W. Lee, W. D. Nix and Y. Cui, Advanced Materials , 25 , 4966 (2013). M. Kocun, A. Labuda, W. Meinhold, I. Revenko and R. Proksch, ACS Nano , 11 , 10097 (2017). H. Sakai, Y. Taniguchi, K. Uosaki and T. Masuda, Journal of Power Sources , 413 , 29 (2019). R. Endo, T. Ohnishi, K. Takada and T. Masuda, The Journal of Physical Chemistry Letters , 13 , 7363 (2022). H. Kim, C.-Y. Chou, J. G. Ekerdt and G. S. Hwang, The Journal of Physical Chemistry C , 115 , 2514 (2011).

Analysis of Lithiation and Delithiation Kinetics in Silicon

In Situ Atomic-Scale Imaging of Electrochemical Lithiation in Silicon.

Two-phase electrochemical lithiation in amorphous silicon

Sandwich-Lithiation and Longitudinal Crack in Amorphous Silicon Coated on Carbon Nanofibers

First principles simulations of the electrochemical lithiation and delithiation of faceted crystalline silicon

Kinetics of initial lithiation of crystalline silicon electrodes of lithium-ion batteries.

Measurement and modeling of the mechanical and electrochemical response of amorphous Si thin film electrodes during cyclic lithiation

In Situ Measurements of Stress-Potential Coupling in Lithiated Silicon

Lithiation of SiO2 in Li-ion Batteries: in Situ Transmission Electron Microscopy Experiments and Theoretical Studies.

In Situ Measurements of Stress Evolution in Silicon Thin Films During Electrochemical Lithiation and Delithiation

Asymmetric Rate Behavior of Si Anodes for Lithium‐Ion Batteries: Ultrafast De‐Lithiation versus Sluggish Lithiation at High Current Densities

Impact of the Crystalline Li15Si4 Phase on the Self-Discharge Mechanism of Silicon Negative Electrodes in Organic Electrolytes

Lithium Diffusion in Silicon and Induced Structure Disorder: A Molecular Dynamics Study

Probing the Reactivity of the Active Material of a Li-Ion Silicon Anode with Common Battery Solvents

Shedding X-ray Light on the Interfacial Electrochemistry of Silicon Anodes for Li-Ion Batteries.

Operando Nanomechanical Mapping of Silicon Thin Film Electrode during the First Lithiation and Delithiation Investigated By Bimodal Atomic Force Microscopy

On plastic deformation and fracture in Si films during electrochemical lithiation/delithiation cycling

Unraveling the Atomic‐scale Mechanism of Phase Transformations and Structural Evolutions during (de)Lithiation in Si Anodes

Investigation of Initial Lithiation of Silicon (100) Using Solid-State 7Li NMR

Molecular dynamic investigation of the structure and stress in crystalline and amorphous silicon during lithiation

Multi-scale analysis of an electrochemical model including coupled diffusion, stress, and nonideal solution in a silicon thin film anode