Abstract:Electro-reduction of O2 to generate H2O2 is an attractive alternative to the current anthraquinone process and quietly necessary for the chemical industries and environmental remediation. It is general that sufficient porous structure contributes to expose more catalytic active sites and shorten diffusion paths for the heterogeneous catalysis of O2. In this work, initially, the Fe3O4 nanoparticles embedded graphite felt (Fe3O4@GF) is prepared through a mild hydrothermal following with thermal reduction method. This special combination not only provides iron source for the electro-Fenton reaction, but also supplies rich active sites from the Fe3O4 embedded structure with abundant cracks, which are beneficial to increase the reaction rate. Compared with raw graphite felt (RGF), the fresh Fe3O4@GF exhibits superior pollutant degradation kinetics with more than 400% increase and approximately 37.8% improvement to the removal of total organic carbon. 98% decolorization of rhodamine B (RhB) can be achieved in just 5 minutes, and quickly complete 100% removal of RhB in the next few seconds. As the electro-Fenton reaction progresses, Fe3O4 dissolves in the electrolyte, leaving porous structure on the surface of the GF to form a porous GF (PGF), and the rapid radical reaction activates GF surface. Both the chemical etching of Fe3O4 and the electro-Fenton process can further increase the specific surface area, defects and actives sites of the electrode. As expected, the active PGF exhibits favorable performance of H2O2 production among in pH=1 (320.0±36.5 mg L-1), 3 (301.9±13.2 mg L-1) and 7 (320.4±21.2 mg L-1) electrolyte. The degradation performance of PGF does not significantly decay even after 20 times repeated use, indicating the good structural stability and long-term durability. The superiority of the in-situ Fe source and fast reaction kinetics for electro-Fenton of Fe3O4@GF is confirmed, and this holey-engineered strategy also provides the possibility to achieve swift water purification and open up a new way for developing efficient carbon-based electrodes.

Simultaneous enhancement of sludge dewaterability and phosphorus recovery by Fenton-like process with in-situ synthesized green iron-cerium particles

Enhanced sludge dewatering using a novel synergistic iron/peroxymonosulfate-polyacrylamide method

Enhanced dewatering extent of sludge by Fe3O4-driven heterogeneous Fenton

Simultaneously Providing Iron Source towards Electro-Fenton Process and Enhancing Hydrogen Peroxide Production via a Fe3O4 Nanoparticles Embedded Graphite Felt Electrode.

Fe-enhanced primary sedimentation, acidogenic sludge fermentation and electrodialysis for resource recovery from domestic wastewater

Enhancement of waste-activated sludge dewaterability using combined Fenton pre-oxidation and flocculation process

A novel approach using protein-rich biomass as co-fermentation substrates to enhance phosphorus recovery from FePs-bearing sludge

Enhanced electro-Fenton catalytic performance with in-situ grown Ce/Fe@NPC-GF as self-standing cathode: Fabrication, influence factors and mechanism

Sludge dewaterability improvement with microbial fuel cell powered electro-Fenton system (MFCPEFs): Performance and mechanisms

Simultaneous enhancing phosphorus recovery and volatile fatty acids production during anaerobic fermentation of sewage sludge with peroxydisulfate pre-oxidation

A novel iron-based composite flocculant for enhanced wastewater treatment and upcycling hazardous sludge into trifunctional electrocatalyst

Organic binding iron formation and its mitigation in cation exchange resin assisted anaerobic digestion of chemically enhanced primary sedimentation sludge

Synthesis of Fe-N doped porous carbon/silicate composites regulated by minerals in coal gasification fine slag for synergistic electrocatalytic treatment of phenolic wastewater

Synergetic sludge conditioning by US enhanced Fe2+ activated sodium persulfate: Physicochemical properties and mechanisms

Advanced Treatment of Paper Mill Wastewater Using Electro-Fenton Process with Novel Catalytic Particle Electrodes

Enhanced phosphate pollutant removal from liquid via adsorption flotation strategy: Synergic effect of Fe(III)-fulvic acid carrier and CTAB

Iron-enhanced Primary Sedimentation and Acidogenic Sludge Fermentation to Achieve Self-Sufficient Organic Carbon Supply for Enhanced Nutrient Removal in Wastewater Treatment✰

Innovative treatment of industrial effluents through combining ferric iron and attapulgite application

Electro-fermentation of Iron-Enhanced Primary Sedimentation Sludge in a Two-Chamber Bioreactor for Product Separation and Resource Recovery.

Recovery of iron phosphate from secondary sludge by ascorbic and citric acids

Improvement of Sludge Dewatering Performance by Persulfate Advanced Oxidation Combined with Ldh: Synergistic Effect of Free Radical and Non-Free Radical and Reuse of Deep-Dewatered Sludge Cake