Abstract:Superhydrophobic membrane is favorable for the membrane distillation technology in desalination applications although the theoretic reasons are still unsettled. In this study, some novel theories were first proposed to establish the bridges between the surface parameters (including water contact angle and surface roughness) and the heat and mass transfer process. Based on the hydrophobic PVDF membrane (with a water contact angle of 124°), a kind of superhydrophobic PVDF membrane with water contact angle of 162° was prepared through the surface modification. Then both membranes were tested in the VMD process, and simulation models based on both kind of membranes were constructed to compare the membrane performances and the heat and mass transfer characteristics. The results show that the slip flow exists on the superhydrophobic surface, and the superhydrophobic membrane has higher permeate flux than the original PVDF membrane. The insight investigations show that the heat transfer resistance (HTR) of the VMD process is focused on the membrane layers, and the variation of water contact angle or roughness has little influence on the heat transfer coefficient of the membrane layers. However, when the water contact angle varies from 124° to 165°, the total HTR value decreases from 3.156 × 10-3 (m2 K)/W to 2.599 × 10-3 (m2 K)/W, which indicates that the feed side HTR value is largely decreased by the superhydrophobic surface. The further polarization investigations found that the temperature polarization coefficient (TPC) changes slightly when the membrane contact angle varies from 124° to 165°. Instead, the concentration polarization coefficient (CPC) decreases from 0.1455 to 0.0071. The vapor polarization coefficient (VPC), comprehensively considered the influences of TPC and CPC, has a value of above 0.96 when the water contact angle is higher than 155°, which indicates that the performance of the superhydrophobic membrane is not limited by the polarization problems.

Heat and mass transfer enhancement in conductive heating vacuum membrane distillation using graphene/silica modified heat carriers

Conductive heating vacuum membrane distillation for brine desalination: Study on operational conditions, temperature polarization and energy consumption

Enhance the anti-scaling performance of conductive heating vacuum membrane distillation by carbon nanotube-based electroactive membrane

Superhydrophobic-slip surface based heat and mass transfer mechanism in vacuum membrane distillation

Enhanced Performance of Membrane Distillation Using Surface Heating Process

Thermal performance of hydrophobic α-Al2O3 ceramic membrane for solar-thermal membrane coupling water desalination process

Multistage Surface-Heated Vacuum Membrane Distillation Process Enables High Water Recovery and Excellent Heat Utilization: A Modeling Study

Study on Low Thermal-Conductivity of PVDF@SiAG/PET Membranes for Direct Contact Membrane Distillation Application

Roughness-enhanced hydrophobic graphene oxide membrane for water desalination via membrane distillation

Enhancing Heat and Mass Transfer in Adsorption Cooling and Desalination Systems Using Ionic Liquid and Graphene Consolidated Composites

Conducting thermal energy to the membrane/water interface for the enhanced desalination of hypersaline brines using membrane distillation

Nanotexturing-enhanced Heat Transfer and Interfacial Evaporation for Energy-Efficient Solar-Thermal Water Desalination

Hybridized high concentration photovoltaic unit with enhanced performance air gap membrane distillation unit via depositing reduced graphene oxide layer upon the condensation plate using electrophoretic deposition technique

Numerical investigation on mass and heat transfer performance for novel vacuum membrane distillation modules enhanced by semicircular spacers

Electrothermal hollow fiber membrane for convenient heat management in Joule vacuum membrane distillation

Research on the Performance and Computational Fluid Dynamics Numerical Simulation of Plate Air Gap Membrane Distillation Module

Self-heating Janus Separable CNT-PVA@CC/HPo-PVDF Membrane Coupling Photothermal and Electrothermal Effects for High-Oil Resistance, High-Efficiency and Stable Membrane Distillation

Amelioration of pool boiling thermal performance utilizing graphene-silver hybrid nanofluids

Engineering anti-scaling superhydrophobic membranes for photothermal membrane distillation

Enhanced Evaporation Performance of Solar Interface Evaporator by Modifying the Evaporation Layer Surface with Hydrophobic Fumed Silica

Heat and Mass Transfer Characteristics of Vacuum Membrane Distillation Solution Regeneration Based on Hollow Fiber Membrane