Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Hydrodynamics of evaporating sessile drops

Evaporation and fluid dynamics of a sessile drop of capillary size

Marangoni convection in an evaporating water droplet

Fluid flow structures in an evaporating sessile droplet depending on the droplet size and properties of liquid and substrate

Three-Dimensional Numerical Simulation on Marangoni Convection in a Sessile Water Droplet Evaporating in Its Vapor at Low Pressure

Evaporation and Marangoni Driven Convection in Small Heated Water Droplets

Marangoni Convection Instability in an Evaporating Droplet Deposited on Volatile Liquid Layer

Transient flow patterns in an evaporating sessile drop: A numerical study on the effect of volatility and contact angle

Modeling unsteady Bénard-Marangoni instabilities in drying volatile droplets on a heated substrate

Influence of thermal properties on hydrothermal waves in evaporating sessile droplets

Transition of Marangoni convection instability patterns during evaporation of sessile droplet at constant contact line mode

Marangoni convection instability in a sessile droplet with low volatility on heated substrate

Bénard-Marangoni Instability in Sessile Droplet Evaporating at Constant Contact Angle Mode on Heated Substrate

Droplet Evaporation to Boiling in Van Der Waals Fluid

Numerical Study On Evolution Of Sessile Water Droplets During Evaporation

Dynamics of an evaporating drop migrating in a Poiseuille flow

Hydrothermal Waves in Sessile Droplets Evaporating at a Constant Contact Angle Mode

Evaporation of sessile droplet on surfaces with various wettability

Marangoni instability in oblate droplets suspended on a circular frame

Evaporation Dynamics of Sessile Droplets: The Intricate Coupling of Capillary, Evaporation, and Marangoni Flow

Experimental Investigation on Marangoni Convection Instability Induced by Evaporation in a Sessile Droplet of Silicone Oil on a Heated Substrate