Abstract:Ducted propeller is a kind of special propeller widely used in unmanned underwater vehicles, its flow characteristics and hydrodynamic noise are very important for marine environmental protection and equipment concealment. The hybrid techniques based on the acoustic analogy theory are adopted in the present study to calculate the unsteady flow field and sound field characteristics of a ducted propeller. The full scale flow filed and hydro-acoustic sources of the propulsion system are simulated by Detached-Eddy computational fluid dynamics (CFD) method. Hydrodynamic noise are calculated by FWH equation based on the CFD results. The frequency domain and directivity of sound pressure level at different sound field monitoring points are analyzed at four navigational speeds. The results show that the navigational speed that is in the inflow condition of the ducted propeller play important roles in the flow structure and underwater radiated noise. Under the fixed impeller rotational speed, the propulsion efficiency of ducted propeller increases first and then decreases with the raise of navigational speed. The maximum errors of thrust and power between simulation and experiment values are 0.5% and 0.1% respectively, which means that the adopted DES numerical simulation method has high credibility in calculating the acoustic source. At impeller rotational speed of 2000 r/min, the best state of flow field distribution is at the navigational speed of 1.54 m/s, which is corresponding to the highest propulsion efficiency condition. The propeller noise presents dipole characteristic in all working conditions, and at the obvious blade passing frequency, multiple characteristics are presented; most of the noise contribution is also concentrated below four times of the blade passing frequency. The total sound pressure level of the hydrodynamic noise is the smallest at the optimal efficiency condition (the navigational speed is 1.54 m/s). At high navigational speed, the low frequency characteristics below blade passing frequency increase and the amplitude becomes larger. This indicates that the component of turbulent noise becomes more important with the increase of navigational speed. The research focuses on analyzing the relationship between the energy loss of the ducted propeller wake field and the noise level, and it is found that the vortex at the tail makes a certain contribution to the noise. The research conclusions could provide some reference for the acoustic performance evaluation and noise reduction optimization of ducted propeller design as well as the improvement of UUV stealth performance.

Evaluation of different FW-H surfaces and modal decomposition techniques for the acoustic analysis of UAV propellers through detached eddy simulations

Experimental Study to Quantify the Rotor-to-Rotor Interaction Characteristics of a Small Unmanned-Aerial-Vehicle

On the prediction of noise generated by urban air mobility (UAM) vehicles. Part 2. Implementation of the Farassat F1A formulation into a modern surface-vorticity panel solver

Numerical Prediction of Aerodynamic Noise for a Propeller-wing Configuration and an Investigation of Pitch Effect

Aeroacoustic modeling of helicopter transonic rotor noise

Extrapolation and inversion of near-field propeller noise measurements

Numerical Investigation of Airfoilrotor Interaction at Low Reynolds Number

Unsteady Responses and Correlation Characteristics of Propeller Blades under Turbulence Excitation

A comparison of tonal-broadband decomposition algorithms for propeller noise

A multivariate and wavelet-based analysis on the wall pressure fluctuations for propellers in ground effect

Aeroacoustic sources analysis of wake-ingesting propeller noise

Toward high-efficiency low-noise propellers: A numerical and experimental study

Numerical studies on small rotor configurations with validation using acoustic wind tunnel data

Evaluation of the helicoidal surface theory for the noise prediction of small UAS propellers

Integrated Evaluation of the Aeroacoustics and Psychoacoustics of a Single Propeller

A Computational Aeroacoustic Study of a Multi-Rotor Powered Urban Air Mobility Vehicle

Numerical study of acoustic source localization of rotor using a novel discrete noise analysis strategy

Psychoacoustic analysis of contra-rotating propeller noise for unmanned aerial vehicles

Investigation into the Hydrodynamic Noise Characteristics of Electric Ducted Propeller

An efficient hybrid aeroacoustic method to predict the noise of a ducted coaxial-rotor UAV

Aeroacoustic Prediction of a Multi-Element Airfoil Using Wall-Modeled Large-Eddy Simulation