Abstract:Aiming for the application of refrigerant two-phase cooling on battery thermal management, this study presented an experimental investigation on the flow boiling characteristics of R1233zd(E) in a parallel mini-channel heat sink, which consisted of 21 channels with the length of 140 mm and the cross section of 1.5 x 1.5 mm(2). Under the saturation pressure of 125 kPa, the boiling curve of R1233zd(E) and the heat transfer coefficient were analyzed under different heat fluxes (5-100 kW/m(2)), mass fluxes (150-600 kg/m(2) s) and inlet subcoolings (2.5-8 K). In addition, the flow pattern was captured using high-speed camera. The results showed that the onset of nucleate boiling was delayed with the increase of refrigerant mass flux and inlet subcooling, while the transition of heat transfer was verified by flow pattern visualization. The measured wall superheat was compared with present correlations, showing that the predicted value was always smaller than the experimental results. Flow boiling on local points showed that the nucleate boiling was triggered later at the channel located at the center axis of the heat sink, meanwhile the approach of critical heat flux was more obvious at channel outlet. Due to the graduate transition of flow boiling mechanism, refrigerant mass flux had limited influence on the local heat transfer coefficient when the heat flux was lower than 30 kW/m(2), while enhancement on heat transfer could be observed with larger mass flux when the heat flux exceeded 30 kW/m(2). The local experimental data of heat transfer coefficient were compared with 6 correlations from the literatures. It was found that the best prediction was presented by Liu and Winterton model with a MAE of 23.4%, while Kim and Mudawar model showed best agreement under different mass fluxes. A simple modification was conducted on Kim and Mudawar model, and the calibrated model presented a better prediction accuracy with the MAE of 17.6% and 83.2% of total data within the error of +/- 30%. (C) 2021 Elsevier Ltd. All rights reserved.

Experimental investigation on stability and evaluation of nanorefrigerant applied on organic Rankine cycle system

Stability and thermodynamic property of TiO2/R141b nanorefrigerants by multi‐objective optimization

Stability and thermal conductivities of hybrid sphere/tube TiO2 nanofluid

Study on the Performance of a Novel Waste Heat Recovery System at Low Temperatures

Experimental Investigation on Flow Boiling Instability of R1233zd(E) in a Parallel Mini-Channel Heat Sink for the Application of Battery Thermal Management

Solidification Behavior of Hybrid Tio2 Nanofluids Containing Nanotubes and Nanoplatelets for Cold Thermal Energy Storage

A Theoretical Comparative Study of Vapor-Compression Refrigeration Cycle using Al2O3 Nanoparticle with Low-GWP Refrigerants

A Theoretical Comparative Study on Nanorefrigerant Performance in A Single-Stage Vapor-Compression Refrigeration Cycle

Experimental Study on the Thermal Properties and Stability of Hybrid Nanofluids and Evaluation of Its Heat Exchange Efficiency

Flow and heat transfer characteristics of nano-organic working fluid during evaporation for organic Rankine cycle

Experimental and Model Research on Nanorefrigerant Thermal Conductivity

Study of vapor compression refrigeration system with suspended nanoparticles in the low GWP refrigerant

Experimental analysis of vapour compression refrigeration system using nano lubricant with refrigerant R-134a

Experimental Investigation of a Refrigerator with a Nano-Refrigerant

The Study on Thermal Performance of Power Generation System Using Organic Rankine Cycle and Reheating Cycle System

Thermodynamic and Energy Efficiency Analysis of a Domestic Refrigerator Using Al2O3 Nano-Refrigerant

Analysis of Cascade Vapor Compression Refrigeration System Using Nanorefrigerants: Energy, Exergy, and Environmental (3E)

Study of thermodynamic, transport and volumetric properties of nanofluids containing ZrO2 nanoparticles in polypropylene glycol, polyvinyl pyrrolidone and water

Nano-Powders Migration and Heat Transfer Characteristics in Nanorefrigerant Boiling Process

An Experimental Study on the Effect of Nanofluids on the Thermal Conductivity and Rheological Properties of a Coolant for Liquids

Experimental Study on Thermal Properties and Light-to-Thermal Conversion Performance of Ionic Liquids Based Nanofluids