Abstract:Agave bagasse is an agricultural residue that has the potential to be used as feedstock biorefineries. However, its complex structure requires a pretreatment step to facilitate the accessibility to carbohydrates for its subsequent conversion. In this study, the capital and operative expenses (CAPEX and OPEX) were simulated for industrial plants processing 500 ton/d of Agave bagasse using different pretreatment platforms for methane production and power generation on experimental data. The scenarios consisted of i) biological, ii) enzymatic, iii) dilute acid, and iv) steam explosion pretreatments and a case-based scenario without pretreatment. All these scenarios included milling, pretreatment, anaerobic digestion, and cogeneration stages. The results showed that those pretreatments carried out under soft conditions (biological and enzymatic) decreased between 2.1 and 2.8 times CAPEX compared to the highest value obtained in the diluted acid and case-based scenarios. The steam explosion, a pretreatment carried out under severe conditions, was less effective reducing CAPEX by only 1.2 times compared to the highest value. Furthermore, compared to the case-base scenario, only the biological pretreatment reduced the OPEX by a factor of 2, whereas the other pretreatments resulted in OPEX that were 2.0 to 3.5 times higher. Among the utilities (cooling water, steam generation, and energy) the steam generation contributed 47% to 76% of the total OPEX. The energy produced (kW⋅h/yr) was approximately twice the energy consumed for all scenarios. A sensitivity analysis demonstrated the robustness of the platforms since fluctuations in the prices of feedstock and raw materials did not impact the total production cost of methane, except for biological and enzymatic pretreatments. For all platforms, the solid loading was the process parameter with the highest impact on the production cost of methane. Overall, the study showed that biological and enzymatic pretreatments had the best economic performance. However, low substrate conversion and the high cost of enzymes and equipment, respectively, remained the main challenges to address in future research.

Analysis of energy return on investment of dry anaerobic digestion for low water alperujo with oxidative, thermal and alkaline pretreatments

Effect of Alkaline Microwaving Pretreatment on Anaerobic Digestion and Biogas Production of Swine Manure.

Improved anaerobic biodegradability of wheat straw, solid cattle manure and solid slaughterhouse by alkali, ultrasonic and alkali-ultrasonic pre-treatment

The effect of alkaline pretreatment on the anaerobic digestion of fruit and vegetable wastes from a central food distribution market

Assessing the potential of olive mill solid waste as feedstock for methane and volatile fatty acids production via anaerobic bioprocesses

Scaling-Up the Anaerobic Digestion of Pretreated Microalgal Biomass within a Water Resource Recovery Facility

Bio-physical pre-treatments in anaerobic digestion of organic fraction of municipal solid waste to optimize biogas production and digestate quality for agricultural use

Efficient Anaerobic Digestion of Microalgae Biomass: Proteins as a Key Macromolecule

Evaluation of Biogas Production from Different Biomass Wastes With/without Hydrothermal Pretreatment

Anaerobic Digestion of Thermal-Alkaline-Pretreated Cephalosporin Bacterial Residues for Methane Production

Optimisation of Ultrasound Pretreatment of Microalgal Biomass for Effective Biogas Production through Anaerobic Digestion Process

Process design and economic evaluation for methane and electricity production from Agave bagasse using different pretreatments

Low-Temperature Pretreatment of Biomass for Enhancing Biogas Production: A Review

Effect of a Sono-Thermal Pre-treatment Over Methane Production, Specific Activities and the Microbial Community of Sludge Anaerobic Digesters

Anaerobic fermentation of poplar processing residue to produce methane by alkaline hydrogen peroxide (AHP) pretreatment

Stimulating Methane Production from Poultry Manure Digest with Sewage Sludge and Organic Waste by Thermal Pretreatment and Adding Iron or Sodium Hydroxide

Anaerobic Co-Digestion of Agro-Industrial Waste Mixtures for Biogas Production: An Energetically Sustainable Solution

Effect study of ultrasonic/alkaline pretreatment on anaerobic digestion of penicillin bacterial residue

Optimisation of anaerobic co-digestion in two-stage systems for hydrogen, methane and biofertiliser production

Pretreatments for enhanced biomethane production from buckwheat hull: Effects on organic matter degradation and process sustainability

Evaluation and modelling of methane production from corn stover pretreated with various physicochemical techniques