Abstract:Despite the extensive research that has been conducted for decades on the behavior of confined liquids, detailed knowledge of this phenomenon, particularly in the mixed/boundary lubrication regime, remains limited. This can be attributed to several factors including the difficulty of direct experimental observations of the behavior of lubricant molecules under non-equilibrium conditions, the high computational cost of molecular simulations to reach steady state, and the low signal-to-noise ratio at extremely low shear rates corresponding to actual operating conditions. To this end, we studied the correlation between the structure formation and shear viscosity of octamethylcyclotetrasiloxane confined between two mica surfaces in a mixed/boundary lubrication regime. Three different surface separations corresponding to two-, three-, and five-layered structures were considered to analyze the effect of confinement. The orientational distributions with one specific peak for $n=2$ and two distributions, including a parallel orientation with the surface normal for $n>2$, were observed at rest. The confined liquids exhibited a distinct shear-thinning behavior independent of surface separations for a relatively low sliding velocity, $V_{\rm x}\lesssim 10^{-1}\,{\rm m/s}$. However, the shear viscosities at $V_{\rm x}\lesssim 10^{-1}\,{\rm m/s}$ depended on the number of layered structures. Newtonian behavior was observed with a further increase in the sliding velocity. Furthermore, we found a strong correlation between the degree of molecular orientation and the shear viscosity of the confined liquids. The magnitude of the shear viscosity of the confined liquids can primarily be determined by the degree of molecular orientation, and shear-thinning originates from the vanishing of specific orientational distributions with increasing sliding velocity.

In situ X-ray Diffraction Studies of a Multilayered Membrane Fluid under Confinement and Shear 1

An <i>in situ</i> shearing x-ray measurement system for exploring structures and dynamics at the solid-liquid interface

Structure formation of surfactant membranes under shear flow

Grazing incidence x-ray diffraction studies of lipid-peptide mixed monolayers during shear flow

X-ray Surface Scattering Studies of Molecular Ordering at Liquid-Liquid Interfaces

Synchrotron X-Ray-scattering Studies on the Sodium Dodecyl Sulfate–water–pentanol–dodecanel3sponge Phase

Nonequilibrium X-Ray Study of the Nematic to Smectic-a Transition under Shear Flow

Structural transitions and arrest of domain growth in sheared binary immiscible fluids and microemulsions

Difference in structural changes of surfactant aggregates near solid surface under shear flow versus those in the bulk

SIMULATION OF MICROSTRUCTURE AND RHEOGICAL PROPERTIES OF SURFACTANT SOLUTION

An Investigation of Non-Fluorous Surfactant Dynol-604 Based Water-in-co2 Reverse Micelles by Small Angle X-ray Scattering

In Situ Synchrotron SAXS Study of Polymerizable Microemulsions

Study of Ordering for AOT/Water Lamellar Lyotropic Liquid Crystal: Small-angle X-ray Scattering Experiments

Concentration effects on the dynamics of liquid crystalline self-assembly: time-resolved X-ray scattering studies

Correlation between ordering and shear thinning in confined liquids

Brownian Dynamics Simulation of Microstructures and Elongational Viscosities of Micellar Surfactant Solution

Surface Effects on Phases Transitions in Smectic Membranes

Ternary Fluid Mixture Confined Between Surfaces: Surface-induced Phase Transition and Long-range Oscillatory Forces

Self-assembled Structures for Surfactant–inorganic Component–water System Confined in Two Flat Walls

Rheology of model confined ultrathin fluid films. I. Statistical mechanics of the surface force apparatus experiments

Quantitative Compositional Mapping of Phase Separation in Thin Polymer Films