Abstract:At present, inhibitors have been widely used in the field of coal fire prevention and control, but there are some defects in the use of them. So it is necessary to find a new practical and economical inhibitor. Dissolvable tiny-foam extinguisher (DTE) is environment-friendly, high in thermal stability, and fast in cooling. In view of the good performance of the product, the thermal behavior effects of DTE on coal spontaneous combustion were investigated through experimental tests. A scanning electron microscopy was used to study changes in the surface microstructure of raw coal after DTE treatment. Laser thermal conductivity analysis and simultaneous thermal analysis were used to test the effects of DTE at mass fraction of 0%, 5%, 10%, and 15% on the thermophysical properties, mass loss, characteristic temperature, and heat release of coal during heating. The surface of the DTE-treated coal sample was covered in a dense film. The treated coal sample had lower thermal diffusivity and thermal conductivity values and a higher specific heat capacity. Moreover, coal treated with DTE showed no obvious oxygen absorption or mass gain during initial heating, and the dry cracking temperature was greatly increased by 37 °C, 53 °C, and 100 °C, respectively. The initial heat release temperature increased by more than 170 °C, and the amount of the initial heat absorption was more than 52.2 times that of untreated samples. Oxidation kinetics were applied to calculate the activation energy of the coal during thermal decomposition and ignition, and the activation energies of the treated samples at the thermal decomposition and combustion stages increased by 161%, 179%, and 173%, respectively. From these results, we concluded that DTE could inhibit heat accumulation by blocking oxygen contact with the coal and greatly reducing heat release during heating. Besides, only a small quantity of DTE was needed to effectively inhibit coal self-ignition. These results provide reference for the field application of DTE in restraining coal spontaneous combustion.

Inhibitory Kinetics and Mechanism of the Low Temperature Oxidation of Coal by Polyethylene Glycol-Citric Acid

Inhibiting effect and mechanism of polyethylene glycol - Citric acid on coal spontaneous combustion

Synergistic inhibition kinetics and mechanisms of polyethylene glycol – citric acid on non-caking coal oxidation at low temperature

Study on the Properties of Proanthocyanidins Modified Temperature Sensitive Gel Composite Inhibitor for Inhibiting Coal Spontaneous Combustion

Investigation of the physicochemical inhibitors on coal spontaneous combustion based experimental and quantum chemical methods

Research on the mechanism of coal adsorption of CO 2 hindering oxygen

Preparation of complex physicochemical synergistic inhibitors and study on inhibition of spontaneous combustion of coal

Research on the effect and mechanism of composite phase change materials inhibiting low-temperature oxidation of coal

Carbon Dioxide Prevents Oxygen Adsorption at Low-Temperature Oxidation Stage of Low-Rank Coal: Laboratory Study and Molecular Simulation

Study on the Inhibition of Coal Spontaneous Combustion by Superabsorbent Antioxidant Inhibitors

Inhibition of coal spontaneous combustion by an environment-friendly, water-based fire extinguishing agent

Effect of Sphingomonas polyaromaticivorans on spontaneous combustion of lignite during low-temperature oxidation

Inhibiting effects of a proanthocyanidins/sodium polyacrylate composite on the spontaneous combustion of long-flame coal

Experimental and simulation study of inert gas mixture inhibiting coal spontaneous combustion

Comparative study on the inhibiting effect of dissolvable tiny-foam extinguishing agent and chlorine salts on coal spontaneous combustion

Preparation of Thermal Controlled Deoxygenation Inhibitor and Its Inhibition of Coal Spontaneous Combustion

Study on the Inhibition Performance of a Lipoic Acid Microcapsule Gel Composite Inhibitor in the Spontaneous Combustion of Coal

Synergistic inhibition effect and mechanism of an inhibitor for entire process inhibition of coal spontaneous combustion

Role of an additive in retarding coal oxidation at moderate temperatures

Development of Curcumin Composite Gel Inhibitor for Preventing Spontaneous Combustion of Coal

A study of the inhibition properties of gallic acid/lignin-modified hydrogel inhibitor prepared via graft copolymerization