On the Flip Side of Mask Wearing: Increased Exposure to Volatile Organic Compounds and a Risk-Reducing Solution

Long Jin,Stephen M. Griffith,Zhihan Sun,Jian Zhen Yu,Wan Chan

DOI: https://doi.org/10.1021/acs.est.1c04591

2021-10-01

Abstract:Surgical masks have been worn by the public worldwide during the COVID-19 pandemic, yet hazardous chemicals in the petroleum-derived polymer layer of masks are currently ignored and unregulated. These organic compounds pose potential health risks to the mask wearer through dermal contact or inhalation. Here, we show that surgical masks from around the world are loaded with semivolatile and volatile organic compounds (VOCs), including alkanes, polycyclic aromatic hydrocarbons (PAHs), phthalate esters, and reactive carbonyls at ng to μg/mask levels. Naphthalene was the most abundant mask-borne PAH, accounting for over 80% of total PAH levels; acrolein, a mutagenic carbonyl, was detected in most of the mask samples, and di(2-ethylhexyl) phthalate, an androgen antagonist, was detected in one-third of the samples. Furthermore, there is large mask-to-mask variability of the residue VOCs, revealing the uneven quality of masks. We confirm that masks containing more residue VOCs lead to significantly higher exposure levels and associated disease risks to the wearer, which should warrant the attention of the general public and regulatory agencies. We find that heating the masks at 50 °C for as short as 60 min lowers the total VOC content by up to 80%, providing a simple method to limit our exposure to mask-borne VOCs.The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acs.est.1c04591.Place of manufacture of the mask samples; analyte list of aldehydes, PAHs, phthalate esters and their detection parameters and method accuracy; summary of VOC/SVOC amounts in the 60 face mask samples; photograph showing the experimental setup to measure the ambient VOC concentration in the behind-mask breathing zone using the NIOSH sorbent tube-based sampling method and its VOC collection efficiency; chromatograms showing the VOC profile of three representative surgical masks; mass amount of PAHs and phthalates of the tested samples; chromatograms showing the VOC profile of ambient air in a typical surgical mask and that in the breathing zone when wearing the mask; concentration profile of inhalable toluene over the mask usage time; and relative VOC amounts in masks before and after unpacking and baking treatments (PDF)This article has not yet been cited by other publications.

environmental sciences,engineering, environmental