Abstract:Abstract Background Napier grass biomass can be hydrolyzed mainly containing glucose and xylose after alkaline pretreatment and enzymatic hydrolysis. This biomass can be fermented using Actinobacillus succinogenes to produce succinic acid. The yield of succinic acid was 0.58 g/g. Because metabolizing xylose could produce more acetic acid, this yield of succinic acid was lower than that achieved using glucose as the sole carbon source. Results The addition of glycerol as a fermentation substrate to Napier grass hydrolysate increased the reducing power of the hydrolysate, which not only increased the production of succinic acid but also reduced the formation of undesirable acetic acid in bacterial cells. At a hydrolysate:glycerol ratio of 10:1, the succinic acid yield reached 0.65 g/g. The succinic acid yield increased to 0.88 g/g when a 1:1 ratio of hydrolysate:glycerol was used. For the recovery of succinic acid from the fermentation broth, an outside-in module of an ultrafiltration membrane was used to remove bacterial cells. Air sparging at the feed side with a flow rate of 3 L/min increased the filtration rate. When the air flow rate was increased from 0 to 3 L/min, the average filtration rate increased from 25.0 to 45.7 mL/min, which corresponds to an increase of 82.8%. The clarified fermentation broth was then electrodialized to separate succinate from other contaminated ions. After electrodialysis, the acid products were concentrated through water removal, decolorized through treatment with activated carbon, and precipitated to obtain a purified product. Conclusions The yield of succinic acid was increased by adding glycerol to the hydrolysate of Napier grass. The downstream processing consisting of ultrafiltration membrane separation and single-stage electrodialysis was effective for product separation and purification. An overall recovery yield of 74.7% ± 4.5% and a purity of 99.4% ± 0.1% were achieved for succinic acid.

Succinic Acid Production With Actinobacillus succinogenes –Influence of an Electric Potential on the Intercellular NADH/NAD+ Balance

Enhanced production of succinic acid by Actinobacillus succinogenes with reductive carbon source

Effect of Redox Potential Regulation on Succinic Acid Production by Actinobacillus Succinogenes

Improved succinic acid production in the anaerobic culture of an Escherichia coli pflB ldhA double mutant as a result of enhanced anaplerotic activities in the preceding aerobic culture

Process development of succinic acid production by Escherichia coli NZN111 using acetate as an aerobic carbon source

Enhancement of succinate production by metabolically engineered Escherichia coli with co-expression of nicotinic acid phosphoribosyltransferase and pyruvate carboxylase

Improved succinic acid production through the reconstruction of methanol dissimilation in Escherichia coli

Comprehensive investigation of succinic acid production by Actinobacillus succinogenes: a promising native succinic acid producer

Production of succinic acid through the fermentation of Actinobacillus succinogenes on the hydrolysate of Napier grass

Enhanced direct gaseous CO2 fixation into higher bio-succinic acid production and selectivity

Enhanced succinic acid production under acidic conditions by introduction of glutamate decarboxylase system in E. coli AFP111

An End-to-end Pipeline for Succinic Acid Production at an Industrially Relevant Scale using<i>Issatchenkia orientalis</i>

Carbon flux analysis by 13C nuclear magnetic resonance to determine the effect of CO2 on anaerobic succinate production by Corynebacterium glutamicum

Progress on production of succinic acid by Actinobacillus succinogenes – New opportunities for cheap biomass and waste gas utilization

Variables and Mechanisms Affecting Electro-Membrane Extraction of Bio-Succinic Acid from Fermentation Broth

Improved Succinate Production by Metabolic Engineering

Study of the role of anaerobic metabolism in succinate production by Enterobacter aerogenes

Production of succinate by recombinant Escherichia coli using acetate as the sole carbon source

Engineering an electroactive Escherichia coli for the microbial electrosynthesis of succinate from glucose and CO2

Co-expression of Phosphoenolpyruvate Carboxykinase and Nicotinic Acid Phosphoribosyltransferase for Succinate Production in Engineered Escherichia Coli.

Continuous Production of Succinic Acid Using an External Membrane Cell Recycle System