Abstract:To handle the gangue well and control the settlement of the surface, as well as to reduce the risk of water bleeding, settlement and even blockage and pipe breaking of the gangue slurry in the process of conveying, the rheological characteristics of the slurry should be studied. The rheological properties of slurry with different concentrations prepared from gangue samples of the Ningtiaota coal mine were tested, and the correlation between the rheological characteristics of the coal gangue filling slurry and three factors, namely the gangue mass fraction, grain gradation and standing time, were studied by a single factor method and response surface methodology. The results show that the fitting curve of the Herschel–Bulkley model is mostly linear, that is, the shear stress of coal gangue paste increases as a function of the shear rate. Therefore, these two concentrations are too small to form a stable network structure to wrap large particles and can easily cause pipe blockage. The yield shear stress and plastic viscosity show an exponential increase with the increasing mass fraction. The shear stress and apparent viscosity of the pastes with mass fractions of 60% and 65%, respectively, increase significantly after 20, 40 and 60 min of standing. According to the comprehensive test results and the response surface, the optimization method is as follows: mass fraction of 72%; aggregate grading for 4.75~1.18 mm particle size is 30%, for 1.18~0.425 mm particle size is 40%, for 0.425~0.075 mm particle size is 10%, for less than 0.075 mm particle size is 20%; with different standing times, the yield shear stress of slurry ranges from 103.02 to 131.645 Pa; and the plastic viscosity ranges from 0.54 to 0.64 Pa.s. With the increase of the standing time, the slurry settlement is relatively small, and is a more ideal gangue slurry proportion.

Rheological Properties of High Concentration Coal Slime

An Investigation on Characteristics of Coal–water Slurry Prepared from the Solid Residue of Plasma Pyrolysis of Coal

Influence of Dispersants on Coal-Water Slurry Prepared from the Solid Residue of Plasma Pyrolysis of Coal

Evaluating the influence of coal particle size gradation on the properties of coal–water slurry

Slurrying characteristics of low-volatile coal and the rheological characteristics of coal water slurry

Rheology and Thixotropic Properties of Slurry Fuel Prepared Using Municipal Wastewater Sludge and Coal

Slurry Ability of Coal Water Slurry Prepared with Two Kinds of Sewage Sludge

Study on basic features of sludge coal water slurry

Rheological behavior in Xinglongzhuang coal washery sludge pump system of CFB boiler

The Enhancement on Rheology, Flowability, and Stability of Coal Water Slurry Prepared by Multipeak Gradation Technology

INFLUENCE OF THE COAL'S PHYSICAL CHEMISTRY PROPERTY TO ITS SLURRYING QUALITY

The Slurrying Properties of Coal Water Slurries Containing Raw Sewage Sludge

Slurryability of Coal Water Slurry Prepared by Inner Mongolia Brown Coal

Study on the Slurrying and Rheological Properties of Coal–oilfield Wastewater–slurry

Hot Water Treatment of Low Rank Coal in High Temperature and High Pressure Reactor and Its Slurry Ability

Effects of Modified Sodium Lignosulfonate on Rheological Properties of Coal–Water Slurry with Low-Rank Coal

Experimental Study on Rheological Properties of Coal Gangue Slurry Based on Response Surface Methodology

Experimental Research on Morphology and Drying Characteristics of Coal Slime Dough Injected into Circulating Fluidized Bed Boiler

Study on properties of coal-sludge-slurry prepared by sludge from coal chemical industry

Experimental Studies on Coal Water Slurries Prepared from Coal Gasification Wastewater

Pore Characteristics and Slurryability of Coal Blends