Abstract:Transient three-dimensional numerical simulations of power-law fluid flow in an annular channel with a diameter ratio of 1/2 were performed. The outcomes of the simulations using the URANS approach were contrasted with the results of the RANS and LES approaches for Newtonian and power-law fluids. It was demonstrated that comparable outcomes to those obtained through LES can be achieved through URANS with a reduced computational cost. It was determined that the RANS approach tends to underestimate turbulent kinetic energy and pressure losses. Parametric studies were conducted using the URANS approach, encompassing a range of Reynolds numbers ( Re ) between 100 and 10,000, dimensionless rotation rates ( N ) values between 0.2 and 5, and power-law indices ( n ) between 0.4 and 1. The following flow regimes were identified: (1) flow without vortices; (2) Taylor-type toroidal vortices; (3) Görtler-type continuous spiral vortices swirling around the inner cylinder; and (4) small-scale Görtler-type vortices near both channel walls. The numerical experiments demonstrated that the rotation of the inner cylinder resulted in three notable effects: a reduction in the apparent viscosity within the vicinity of the rotating cylinder, a decline in viscous shear stresses, and the development of Görtler-type vortex structures, which contributed to an increase in energy losses. Additionally, at Reynolds numbers below 300, high rotation led to the formation of Taylor-type vortices and a reduction in pressure losses. The power law fluid requires increased rotation of the inner cylinder to form vortices and transition the flow to turbulent. When the Reynolds number is less than 300, the first mechanism is the dominant factor, resulting in a reduction in pressure loss. At Reynolds numbers of approximately 300, the first two mechanisms are in competition, with the pressure loss dependent on the power law index, n . Finally, at Reynolds numbers greater than 300, secondary vortex structures, such as Görtler vortices, become the dominant factor, leading to an increase in pressure loss with rotation.

An investigation of a gas-liquid swirling flow with shear-thinning power-law liquids

Close-contact Melting of Shear-Thinning Fluids

Decay law and swirl length of swirling gas-liquid flow in a vertical pipe

Gas-liquid swirling flow behaviors and liquid-carrying mechanism inside a horizontal pipe

Numerical Simulation on the Flow Pattern of a Gas-Liquid Two-Phase Swirl Flow

Experimental Investigation of Flow-Induced Vibration in Gas/Shear-Thinning Liquid Flows in Vertical Pipe

Research on the flow around a circular cylinder near a wall for shear-thinning power-law fluids

Flow of Power-Law Fluid Past a Circular Cylinder in the Vicinity of a Moving Wall

Hydrodynamics of gas/shear-thinning liquid two-phase flow in a co-flow mini-channel: Flow pattern and bubble length

CFD simulation on shear-thinning gas-liquid dispersion in coaxial mixer

Detailed Numerical Simulation of Swirling Primary Atomization Using a Mass Conservative Level Set Method

A review for measurements and simulations of swirling gas-particle flows

Experimental Investigation on Submerged Gas-Liquid Mixture Injection into Water Through A Micro-Channel

Research on the Gas-Liquid Two-Phase Distribution Behavior and Influencing Factors of Swirling Flow in Horizontal Pipe

Periodic and aperiodic bubbling in submerged gas-liquid jets through a micro-channel

Numerical Study on the Distribution of Rodlike Particles in Laminar Flows of Power Law Fluids Past a Cylinder.

Stability of Core-Annular Flow of Power-Law Fluids in the Presence of Interfacial Surfactant

Experimental study of two-phase flow structure in churn-turbulent to annular flows

Turbulent spiral flow of power-law fluid in annular channel

Flow pattern and pressure drop of gas-liquid two-phase swirl flow in a horizontal pipe

Numerical Investigation of Confined Swirling Gas-Solid Two Phase Jet