Abstract:By varying the oil volume fraction, the microscopic droplet size and the macroscopic rheology of emulsions are investigated in a Taylor–Couette turbulent shear flow. Although here oil and water in the emulsions have almost the same physical properties (density and viscosity), unexpectedly, we find that oil-in-water (O/W) and water-in-oil (W/O) emulsions have very distinct hydrodynamic behaviours, i.e. the system is clearly asymmetric. By looking at the micro-scales, the average droplet diameter hardly changes with the oil volume fraction for O/W or for W/O. However, for W/O it is about larger than that of O/W. At the macro-scales, the effective viscosity of O/W is higher when compared to that of W/O. These asymmetric behaviours are expected to be caused by the presence of surface-active contaminants from the walls of the system. By introducing an oil-soluble surfactant at high concentration, remarkably, we recover the symmetry (droplet size and effective viscosity) between O/W and W/O emulsions. Based on this, we suggest a possible mechanism responsible for the initial asymmetry and reach conclusions on emulsions where interfaces are fully covered by the surfactant. Next, we discuss what sets the droplet size in turbulent emulsions. We uncover a scaling dependence of the droplet size on the Reynolds number of the flow. Combining the scaling dependence and the droplet Weber number, we conclude that the droplet fragmentation, which determines the droplet size, occurs within the boundary layer and is controlled by the dynamic pressure caused by the gradient of the mean flow, as proposed by Levich (Physicochemical Hydrodynamics, Prentice-Hall, 1962), instead of the dynamic pressure due to turbulent fluctuations, as proposed by Kolmogorov (Dokl. Akad. Nauk. SSSR, vol. 66, 1949, pp. 825–828). The present findings provide an understanding of both the microscopic droplet formation and the macroscopic rheological behaviours in dynamic emulsification, and connects them.

Experimental measurements of stress redistribution in flowing emulsions

Topological rearrangements and stress fluctuations in quasi-two-dimensional hopper flow of emulsions

Experimental Observation of Local Rearrangements in Dense Quasi-Two-dimensional Emulsion Flow.

Lagrangian statistics of dense emulsions

Wide-gap Couette flows of dense emulsions: Local concentration measurements, and comparison between macroscopic and local constitutive law measurements through magnetic resonance imaging

Experimental study of forces between quasi-two-dimensional emulsion droplets near jamming

Investigation of local and temporal interfacial shear stress distribution during membrane emulsification

Emulsions in microfluidic channels with asymmetric boundary conditions and directional surface roughness: stress and rheology

Rearrangements during slow compression of a jammed two-dimensional emulsion

Modeling drop deformations and rheology of dilute to dense emulsions

Experimental observations of fractal landscape dynamics in a dense emulsion

Linear and nonlinear rheology of dense emulsions: Identifying the glass and jamming regimes

Flowing emulsions through disorder: Critical depinning and smectic rivers

Rayleigh-Bénard convection of a model emulsion: anomalous heat-flux fluctuations and finite-size droplets effects

Dynamical regimes of thermally convective emulsions

Hydrodynamic fluctuations in confined emulsions

Avalanches of Rearrangements in 2D Emulsion Hopper Flow

Physical mechanisms for droplet size and effective viscosity asymmetries in turbulent emulsions

Build up of yield stress fluids via chaotic emulsification