Abstract:Over the past two decades the use of near-/super-critical carbon dioxide has received much attention as a green alternative to organic solvents for chemical reactions, separations, and extractions because of its pressure-tunable physicochemical properties and economic advantages. However the advantages are diminished because of a relative narrow range of CO2-soluble materials. The goal of this work is to identify, design and synthesize oxygenated hydrocarbon-based CO2-soluble polymers that are able to serve as construction blocks for copolymers, dispersants, surfactants, thickeners, and chelating agents. Without concerning on the cost and the environmental persistence like fluorinated materials, the inexpensive, environmentally benign materials would significantly enhance the viability of near-/super-critical carbon dioxide-based technology. Based on both experimental heuristics and ab initio simulation results of molecular modeling (performed by Dr. Johnson's group), we proposed specific new polymer structures: poly(3-acetoxy oxetane) (PAO), poly(vinyl methoxymethyl ether) (PVMME), poly(vinyl 1-methoxyethyl ether) (PVMEE), and cellulose triacetate (CTA) oligomers. Phase behavior studies were also performed with novel CO2-philic compounds containing vinyl acetate, propylene glycol, or multiple tert-butyl groups. PAO, PVMME and PVMME were soluble in CO2, but not as soluble as poly(vinyl acetate). Oligomers of cellulose triacetate with as many as four repeat units solubilized into dense CO2 less than 14 MPa in the concentration range of 1-5 wt%. Phase behaviors of more than thirty compounds in dense CO2 were studied in this project. A new type of phase behavior for solid (at ambient temperature) CO2-philes that melt and dissolve in CO2 was detailed using a model binary mixture of β-D-maltose octaacetate and CO2. Copolymers of tetrafluoroethylene (TFE) and vinyl acetate (VAc) exhibited lower miscibility pressures than either of the homopolymers, probably due to quadradentate binding configurations with CO2. Phase behavior investigation of poly(propylene glycol) (PPG) monobutyl ether in CO2 demonstrated ether-CO2 interactions should receive as much attention as carbonyl-CO2 interactions when designing CO2-philic functional groups. 1,3,5-tri-tert-butylbenzene and tri-tert-butyl-phenol were both extraordinarily soluble in CO2, and are excellent candidates for CO2-soluble sand binders. In summary, although a new CO2 thickener was not identified, new non-fluorous CO2-soluble materials were identified that were, in general, acetate-rich with flexible chains, weak self-interactions, and multidentate interaction between CO2 and solute functional groups.

Dissolution behaviors of alkyl block polyethers in CO2: Experimental measurements and molecular dynamics simulations

Solubilities of Dodecylpolyoxyethylene Polyoxypropylene Ether in Supercritical Carbon Dioxide

Promoting dissolution behaviors of low-carbon alcohol polyoxyethylene polyoxypropylene ether in CO 2 by molecular structure optimization and adding cosolvent

Molecular dynamics study on the dissolution behaviors of poly(vinyl acetate)‐polyether block copolymers in supercritical CO 2

Solubilities of the Triethylene Glycol and Tripropylene Glycol Derivatives Terminated with Phosphoryl Groups in Supercritical Co2

Evaluation of CO2‐philicity and Thickening Capability of Multichain Poly(ether‐carbonate) with Assistance of Molecular Simulations

The influence and mechanism of alkyl block polyethers on the interfacial tension and minimum miscibility pressure of CO 2 and shale oil

Effects of CO 2 -philic nonionic polyether surfactants on miscibility behaviors of CO 2 –hydrocarbon systems: Experimental and simulation approach

A Theoretical Study of Structure-Solubility Correlations of Carbon Dioxide in Polymers Containing Ether and Carbonyl Groups

Synthesis and Phase Behavior of CO<sub>2</sub>-Soluble Hydrocarbon Copolymer: Poly(vinyl acetate-<i>alt</i>-dibutyl maleate)

Effect of oxyethylene and oxypropylene groups on the interfacial structure and property of extended surfactants: Molecular simulation and experimental study

Solubilization of polyalcohol in supercritical co 2 microemulsion | (Chinese Sourse)

Solubility of CO2 in CO2-philic oligomers; COSMOtherm predictions and experimental results

Exploration of Co2-Philicity of Poly(Vinyl Acetate-Co-Alkyl Vinyl Ether) Through Molecular Modeling and Dissolution Behavior Measurement

Surfactant formation efficiency of fluorocarbon-hydrocarbon oligomers in supercritical CO2

Dissolution Behavior of Really Diethylene Glycol Single Ethers in Supercritical Carbon Dioxide

Phase diagrams and microstructures of aqueous short alkyl chain polyethylene glycol ether carboxylate and carboxylic acid triblock surfactant solutions

Solubilization of Polyalcohol in Supercritical CO_2 Microemulsion

Structural Effects of Nonionic Surfactants on Their Ability to Reduce the Dissolution Pressures of Heavy Hydrocarbons in Supercritical CO2

IDENTIFICATION, DESIGN AND SYNTHESIS OF OXYGENATED HYDROCARBON-BASED CO2-SOLUBLE POLYMERS FOR CHEMICAL AND PETROLEUM ENGINEERING APPLICATIONS

Aggregation and clouding behavior of aqueous solution of EO–PO block copolymer in presence of n-alkanols