Abstract:Zero-carbon fuels (H-2/NH3) replacing coal co-firing is a promising way to address carbon emissions. Hydrogen co-firing helps improve combustion stability at low loads and control pollutant emissions. This study used a safer water electrolysis gas (HHO) for the multi-coal co-firing adaptability test. The effects of HHO injection mode and flow rate on combustion intensity, flue gas emissions, and fly ash characteristics were investigated. The results showed that HHO and lean coal/lignite co-firing could significantly increase the combustion temperature. The maximum temperature increases after co-firing were 108 degrees C and 95 degrees C. As the HHO increased, the CO2 in lignite co-firing increased, and CO and unburnt carbon decreased, while the opposite results were observed for lean coal (LC). At the 2200L/h HHO co-firing, CO2 decreases by 14.46 % and 27.22 % for LC premixed co-firing (PC) and staged co-firing (SC). Compared to SC, PC is more conducive to promoting the complete combustion of coke. The NOX emissions of HHO/LC co-firing are lower than those of pure coal, reaching the lowest value of similar to 9 ppm under SC. As the HHO increases, the NOX of Lignite-PC first increases and then slowly decreases, while Lignite-SC has the opposite effect. Although various NOX emission trends are observed under different conditions, the results are dominated by a common mechanism - the competition between NOX reduction caused by HHO gas and the increase in co-firing temperature on NOX generation. The NOX of SC is all lower than that of PC. The SO2 emission from the LC co-firing decreases with the increase of HHO, while the SO2 from lignite increases. The SO2 of LC-SC can be reduced from similar to 142 ppm to 0 ppm. HHO gas injection inhibits the release and oxidation of sulfur in lean coal. The differences in coal types lead to different changes in SO2 of co-firing. HHO gas reduced the SO3 content of lignite fly ash by 38.01 %. The high-temperature reduction atmosphere promotes the decomposition of sulfates and increases SO2 emissions. HHO co-firing refines the particle size of fly ash. The ultra-fine and micron particle matter (PM) increases, and the content of PM>100 mu m in Lignite-SC decreased by 10.32 %.

High concentrations of CO and CO 2 inhibit lignite gasification in supercritical water

Intrapore water–gas shift reaction inhibits coal gasification in supercritical water

Experimental Investigation of the Effects of Inorganic Components on the Supercritical Water Gasification of Semi-Coke

Experimental investigation on carbon microstructure for coal gasification in supercritical water

Comparative Experimental Study on the Co-Firing Characteristics of Water Electrolysis Gas (HHO) and Lean Coal/lignite with Different Injection Modes in a One-Dimensional Furnace

Molecular Dynamics Investigation on the Lignin Gasification in Supercritical Water

Process in supercritical water gasification of coal: A review of fundamentals, mechanisms, catalysts and element transformation

Numerical study on coal gasification in supercritical water fluidized bed and exploration of complete gasification under mild temperature conditions

Effect of CaO on Conversion of Lignite to Hydrogen-Rich Gas in Supercritical Water

Continuous hydrogen generation from lignite in supercritical water

STUDY ON CO-GASIFICATION OF SLUDGE AND COAL IN SUPERCRITICAL WATER

In-situ Decoupling Effect of H2O on the Whole Process of Coal Gasification in MFBRA and TG-FTIR-MS

Competition and Inhibition Effects During Coal Char Gasification in the Mixture of H2o and Co2

Activated Carbon Production from Lignite in Supercritical Water

Experiment and simulation assessment of supercritical underground coal gasification in deep coal seam

Gasification of α-O-4 linkage lignin dimer in supercritical water into hydrogen and carbon monoxide: Reactive molecular dynamic simulation study

Non-catalytic supercritical water partial oxidation mechanism of coal

Pyrolysis of a Low-Rank Coal in Sub- and Supercritical Water

Study on the mechanisms of hydrogen production from alkali lignin gasification in supercritical water by ReaxFF molecular dynamics simulation

Numerical Investigation of Coal Gasification in Supercritical Water with the ReaxFF Molecular Dynamics Method

Strategies of lignite pyrolysis-gasification-oil system for CO2 emission reduction